|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-03-2018, 09:22 PM | #1 |
Not Yet Wild
Join Date: Nov 2018
Posts: 22
|
95 ds has no torque
This ds will go forward and reverse but has no torque. You almost have to push it to get it going. Once it goes it rounds right along. I’m not sure how much aftermarket stuff has been done to this ds. It looks to have a pretty new motor on it. It does have 2 solenoids as well. One confusing thing is the front solenoid is a 36 volt bit this a 48 volt system. The previous owner said this is a relatively new problem and it looks as tho both of these solenoids have been installed for quite some time. Both seem to be functioning properly. Any thought?
Sent from my iPhone using Tapatalk |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-03-2018, 09:23 PM | #2 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 95 ds has no torque
What is the battery pack voltage? And what is it while you accelerate?
Club Car DS driver’s club #59 |
11-03-2018, 09:25 PM | #3 |
Not Yet Wild
Join Date: Nov 2018
Posts: 22
|
Re: 95 ds has no torque
Batteries are all strong
Sent from my iPhone using Tapatalk |
11-03-2018, 09:34 PM | #4 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 95 ds has no torque
Two solenoids makes me think you have a regen 2 cart. If it has a coil on the drivers side solenoid that may be what you have. If so and the solenoid with the coil fails to close good the load will try to go through the coil. It will get hot under the load.
|
11-03-2018, 09:35 PM | #5 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 95 ds has no torque
Regen 2 in ‘95?
Club Car DS driver’s club #59 |
11-03-2018, 09:43 PM | #6 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 95 ds has no torque
If it has 2 solenoids, 1 resistor coil, a rocker switch for Fwd & Rev, "T" type controller and no Tow/Run switch, it is a Regen 1 cart....
Regen 2's came out in '97 or '98 if memory serves me correctly. They had a different controller and a Tow/Run switch. |
11-03-2018, 09:49 PM | #7 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 95 ds has no torque
Regen 1 regen 2 , if it has a coil on the driver side solenoid the coil will try to carry the load if the solenoid fails to work. This will give you low torque.
|
11-03-2018, 09:50 PM | #8 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: 95 ds has no torque
|
11-03-2018, 09:51 PM | #9 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 95 ds has no torque
|
11-03-2018, 10:05 PM | #10 |
Not Yet Wild
Join Date: Nov 2018
Posts: 22
|
Re: 95 ds has no torque
Yes there is a coil on drivers side solenoid. Drivers side is a 48 volt solenoid and passenger side is a 36 volt. Are you saying I should replace the 48 volt one?
Sent from my iPhone using Tapatalk |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Torque i need torque!!!2001 DS | Electric Club Car | |||
New D&D Torque Motor (4:1) - Not Seeing 40% Torque | Electric EZGO | |||
need torque LBS and torque pattern for 2000 club car ds gas transaxle | Gas Club Car | |||
D&D Speed&Torque vs. D&D High Torque | Electric EZGO | |||
Electric Torque vs Gas Torque | Electric Club Car |