|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-23-2015, 10:07 AM | #1 |
Getting Wild
Join Date: Oct 2007
Location: lake city south carolina,29560
Posts: 98
|
2003 club car stops
2003 48 volt ,new batteries cables and speed sensorand now mcor changed,,,while riding the cart it will run fine then its like you switch it off,,i can take my foot off gas pedal then repress it and it will go again ,happens about every quarter mile or so
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-23-2015, 10:15 AM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2003 club car stops
Wow that is a lot of parts replaced....
If this is an IQ cart and it is happening when Regen is engaging, meaning the cart is trying to go faster than the current speed code is allowing, you may need a "Main dropout harness". Early IQ carts had an issue when Regen engaged that caused a false "Main dropout" fault to occur. The harness includes a diode in series with the Tow/Run switch to prevent the Regen current from back feeding into the logic portion of the controller. |
10-23-2015, 11:49 AM | #3 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2003 club car stops
I agree with Sergio. It's very likely that this is your issue.
|
10-23-2015, 02:06 PM | #4 |
Getting Wild
Join Date: Oct 2007
Location: lake city south carolina,29560
Posts: 98
|
Re: 2003 club car stops
harness been changed
|
10-23-2015, 02:09 PM | #5 |
Getting Wild
Join Date: Oct 2007
Location: lake city south carolina,29560
Posts: 98
|
Re: 2003 club car stops
speed sensor was changed awhile ago,the harness was changed after that ,the cart had a mcor fault code was why it was changed,and it was time to replace batteries
|
10-23-2015, 02:15 PM | #6 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2003 club car stops
Did you mean you changed the entire cart harness or just the add-on "Main drop-out harness" off the tow/run switch?
I would suggest You test the diode inside that small dropout harness in case it has failed. |
10-23-2015, 02:40 PM | #7 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2003 club car stops
He ordered a dropout harness from me back in June, I just didn't realize it earlier.
|
10-23-2015, 08:10 PM | #8 |
Gone Wild
Join Date: Jul 2015
Location: Alpharetta, GA
Posts: 226
|
Re: 2003 club car stops
Sounds like the same issue I am trying to resolve in a customers 2006 Precedent. It runs normal at full throttle to 50 feet or so then drops out. Cycle the pedal and repeat over and over. However, when you give just a little throttle it cuts out immediately. I discussed the issue with Club Cars repair trainer and he was stumped as well. After chasing electrical gremlins for a day and resorting to part swapping, I am waiting on a replacement controller to arrive as a last attempt.
|
10-24-2015, 07:55 AM | #9 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2003 club car stops
fbryant1,
Did the problem exist before, during and after all of these parts/upgrades, or did the symptoms changed/improved during any of that time? |
10-26-2015, 02:23 PM | #10 |
Gone Wild
Join Date: Jul 2015
Location: Alpharetta, GA
Posts: 226
|
Re: 2003 club car stops
After much electrical gremlin chasing, the controller was bad in the one I had doing what yours is.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2003 Club Car stops moving | Electric Club Car | |||
2003 cc stops and beeper sounds intermittently | Electric Club Car | |||
2003 Carryall 6 Engine Stops | Gas Club Car | |||
2003 elec cc stops beeps then goes again | Electric Club Car | |||
2003 PDS 36 Volt Stops Running | Electric EZGO |