Ezgo PDS only reverse goes in reverse.

beach cart · 10-22-2013, 06:03 PM

Hey guys need help with this one. Just got caught in pretty hard rain driving on pavement, made it almost home. Cart stopped at stop sign would not go forward. It only goes in reverse in either forward or reverse. Turned off retried, have 1/2 speed reverse and reverse when putting PDS f/r in forward.
Home in garage, controller and wires dry. The solenoid clicks in either direction, not just peddle micro. Alltrax dcx 600, either direction forward or reverse, I get usual 4 green blinks and steady green. What do you think.

rib33024 · 10-22-2013, 06:28 PM

flip to TOW and Dry out the F/R switch on the dash, use a yard blower, or air to dry it out, if that don't do it remove plugs on controller and dry them

beach cart · 10-22-2013, 06:39 PM

I am doing exactly that now, after the air dryout Iwill let sit to night and check later in an hour or two.

rib33024 · 10-22-2013, 07:08 PM

Quote:

Originally Posted by beach cart

I am doing exactly that now, after the air dryout Iwill let sit to night and check later in an hour or two.

The wife's hair dryer helps to, but yeah after it dry's everything should be ok, put a fan on it and let it blow over night if you have one

cbryan88 · 10-22-2013, 07:37 PM

Do these F/R switches fail this easily on PDS carts? this could be my issue...I had my cart do the same exact thing after batt cable re-wire and controller install.....BUT while I had it apart with body off I pulled batts and power washed frame and undercarriage.

I didn't aim for dash area, but I'm sure it got a little wet...after reassembly, my cart did exact same thing as OP's...now after exhaustive checking on all connections and wiring I did, I have isolated it to no voltage present at the F&R pins in harness...

Currently I have 38V at terminals and lugs and B+ pin at controller and buzzer works when jumped, but nothing home as far as go power...I also noticed that factory Batt Bar meter is dead now too...

Don't they anticipate golfers getting caught in the rain???

beach cart · 10-22-2013, 07:50 PM

I have fans on it and will check in a couple of hours for sure. I normally am a fair weather rider, though often, 5000 miles in over a couple of years.

yurtle · 10-23-2013, 05:06 AM

I'm a series dude, but when properly installed, the plastic "firewall" does a great job keeping water, dust, mud, etc. from the back side of the dash. I drive in crazy wet, muddy places and never had a problem with my 12 volt switches getting wet. Do you have a roof and/or windshield?

beach cart · 10-23-2013, 06:35 AM

Not sure what really happened, I have windshield and the plastic firewall is in place with a carbon fiber dash over. I did have larger holes cut for easier access when putting in carbon dash. Either way it rained wicket hard, for 15 or so. Probably leaked down. Ribs idea of the blowers worked. Checked this morning forward and reverse work fine.

yurtle · 10-23-2013, 01:10 PM

I keep my buggy in my garage. It's getting to the point that weather may have played a factor. If your temperature got below the dew point, any moisture in the air would condense on/in any and all parts.

10-22-2013, 06:03 PM	#1
beach cart Gone Wild Join Date: Dec 2011 Location: Jacksonville Beach, FL Posts: 606	Ezgo PDS only reverse goes in reverse. Hey guys need help with this one. Just got caught in pretty hard rain driving on pavement, made it almost home. Cart stopped at stop sign would not go forward. It only goes in reverse in either forward or reverse. Turned off retried, have 1/2 speed reverse and reverse when putting PDS f/r in forward. Home in garage, controller and wires dry. The solenoid clicks in either direction, not just peddle micro. Alltrax dcx 600, either direction forward or reverse, I get usual 4 green blinks and steady green. What do you think.

10-22-2013, 06:28 PM	#2
rib33024 ...................... Join Date: Apr 2009 Location: FT Lauderdale FL. Posts: 16,416	Re: Ezgo PDS only reverse goes in reverse. flip to TOW and Dry out the F/R switch on the dash, use a yard blower, or air to dry it out, if that don't do it remove plugs on controller and dry them

10-22-2013, 07:37 PM	#5
cbryan88 Not Yet Wild Join Date: Sep 2013 Location: Gold Coast, Florida Posts: 40	Re: Ezgo PDS only reverse goes in reverse. Do these F/R switches fail this easily on PDS carts? this could be my issue...I had my cart do the same exact thing after batt cable re-wire and controller install.....BUT while I had it apart with body off I pulled batts and power washed frame and undercarriage. I didn't aim for dash area, but I'm sure it got a little wet...after reassembly, my cart did exact same thing as OP's...now after exhaustive checking on all connections and wiring I did, I have isolated it to no voltage present at the F&R pins in harness... Currently I have 38V at terminals and lugs and B+ pin at controller and buzzer works when jumped, but nothing home as far as go power...I also noticed that factory Batt Bar meter is dead now too... Don't they anticipate golfers getting caught in the rain???

10-23-2013, 05:06 AM	#7
yurtle Gone Mad Join Date: Oct 2009 Location: Buford, GA Posts: 8,988	Re: Ezgo PDS only reverse goes in reverse. I'm a series dude, but when properly installed, the plastic "firewall" does a great job keeping water, dust, mud, etc. from the back side of the dash. I drive in crazy wet, muddy places and never had a problem with my 12 volt switches getting wet. Do you have a roof and/or windshield?

10-23-2013, 01:10 PM	#9
yurtle Gone Mad Join Date: Oct 2009 Location: Buford, GA Posts: 8,988	Re: Ezgo PDS only reverse goes in reverse. I keep my buggy in my garage. It's getting to the point that weather may have played a factor. If your temperature got below the dew point, any moisture in the air would condense on/in any and all parts.

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

10-22-2013, 06:39 PM	#3
beach cart Gone Wild Join Date: Dec 2011 Location: Jacksonville Beach, FL Posts: 606	I am doing exactly that now, after the air dryout Iwill let sit to night and check later in an hour or two.

10-22-2013, 07:50 PM	#6
beach cart Gone Wild Join Date: Dec 2011 Location: Jacksonville Beach, FL Posts: 606	I have fans on it and will check in a couple of hours for sure. I normally am a fair weather rider, though often, 5000 miles in over a couple of years.

10-23-2013, 06:35 AM	#8
beach cart Gone Wild Join Date: Dec 2011 Location: Jacksonville Beach, FL Posts: 606	Not sure what really happened, I have windshield and the plastic firewall is in place with a carbon fiber dash over. I did have larger holes cut for easier access when putting in carbon dash. Either way it rained wicket hard, for 15 or so. Probably leaked down. Ribs idea of the blowers worked. Checked this morning forward and reverse work fine.

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Forum
wiring a reverse light to the reverse buzzer?	Gas Yamaha
Reverse won't go but if I pump gas it slams into reverse	Electric Club Car
2006 ezgo forward is reverse and reverse is forward please help	Electric EZGO
Foward in reverse and reverse in forward	Electric Club Car
Reverse alarm stuck - motor won't run forward or reverse	Electric EZGO