|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
01-25-2022, 04:23 PM | #1 |
Not Yet Wild
Join Date: Jan 2021
Location: texas
Posts: 22
|
where does the red wire connect????
i have a 2003 ezgo txt pds regen i think it is called. the f/r switch is on the dash and i have a tow run switch. where does the red wire from the charge port connect to. it is the red wire with male end in the photo.it is the white then red wire from the reed switch. it has battery voltage.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-25-2022, 06:17 PM | #2 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: where does the red wire connect????
In a stock PDS, the small white wire coming out of the backside of the charge receptacle connects to the red wire that goes across the cart to the passenger side and connects to J1 Pin-4. (See schematic with solenoid activation circuit highlighted).
However, many people bypass the reed switch (which has a nasty habit of failing when you are out in the middle of nowhere) and that wire is unused. Trace the wire on J1 Pin-4 and see where it goes. It need to be connected to a battery pack voltage source for cart to run. |
01-25-2022, 09:00 PM | #3 |
Not Yet Wild
Join Date: Jan 2021
Location: texas
Posts: 22
|
Re: where does the red wire connect????
it is a yellow wire that goes to the solenoid. i will check for voltage in the morning. thanks
|
01-26-2022, 10:02 AM | #4 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: where does the red wire connect????
Quote:
Here's a picture of a PDS controller with Pin-1 on all the jacks highlighted in red. |
|
01-26-2022, 11:01 AM | #5 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,141
|
Re: where does the red wire connect????
The wire in the picture will connect to a wire hanging out of the loom in front of the controller. Should be red with a white stripe.
|
01-26-2022, 02:48 PM | #6 |
Not Yet Wild
Join Date: Jan 2021
Location: texas
Posts: 22
|
Re: where does the red wire connect????
ok... found the red/white wire. it was hooked to battery and i hooked it up correctly. i still have no power to the yellow wire coming from 7 to the b+ small terminal on solenoid. also no power to posts 8 or 9. i do not have power to the key switch. could my controller be bad. i have double checked all the other wiring as per the diagrams i have found. 37 volt on batteries and 37 volts to the big b+ terminal. a shade tree cart mechanic here said it would be the controller..thanks for any help
Last edited by beav1017; 01-26-2022 at 02:55 PM.. Reason: correction |
01-26-2022, 04:18 PM | #7 |
Gone Wild
Join Date: Sep 2017
Posts: 690
|
Re: where does the red wire connect????
Fully charge your batteries first.
Per Johnnieb's chart below (use only as a general reference) your battery pack is only 70% charged for a 36v system. |
|
|
Similar Threads | ||||
Thread | Forum | |||
Where to connect black on board computer wire to Alltrax SR 48500?? | Electric Club Car | |||
Where should this connect? | Electric Club Car | |||
EZGO Ignition Switch Help (where to connect hot wire on Radio to Ignition Switch) | Gas EZGO | |||
3rd pin (signal wire) on receptacle. Where connect? | Electric Yamaha | |||
Where does this battery warning light wire connect? 2003 Club Car DS | Electric Club Car |