|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-17-2014, 05:10 PM | #1 |
Not Yet Wild
Join Date: Jun 2013
Posts: 32
|
state of charge meter reading wrong?
I have a 36v ezgo medalist brand new trojan t105s new motor speed controller fnr switch wires and solenoid. My state of charge meter is showing batteries are almost dead. I let them charge and it still reads almost dead. Im wondering if the state of charge meter is wrong or if it isn't charging. I dont have a volt meter but what components are related to charging? I checked all three wires coming from the spot where it charges and they seem fine.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-17-2014, 05:12 PM | #2 |
Not Yet Wild
Join Date: Jun 2013
Posts: 32
|
Re: state of charge meter reading wrong?
And I have a brand new 5 amp charger. I thought that was the problem so I used my old charger ( which works but the timers bad) still the same
|
05-17-2014, 05:31 PM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: state of charge meter reading wrong?
5 amp charger is not good for the Trojan or any golf cart batteries. Golf cart batteries require amperage equivalent of nearly 10% of their amp hour capacity in the bulk replenishment or initial stage of charging... they also require an algorithm which only GC chargers can do.
Even if you got the small T605s they have a 200 AH capacity and require close to 20amps. The T105s are 225 AH capacity. You Need an 18amp min charger. Hard to say if you have the meter hooked up wrong or the batteries are getting low without a handheld meter to check things with. |
05-17-2014, 05:55 PM | #4 |
Gone Wild
Join Date: Sep 2012
Location: Savannah, GA
Posts: 2,760
|
Re: state of charge meter reading wrong?
what type state of charge meter do you have? Bar, analog round gauge or digital meter?
The bar type need reset once in a while. To do this disconnect one of the meter wires at the battery for a minute then reconnect it. The bar meter should reset. Analog round gauge and digital do not need a reset ever. |
05-17-2014, 06:32 PM | #5 |
Getting Wild
Join Date: Jun 2012
Location: Michigan
Posts: 117
|
Re: state of charge meter reading wrong?
And spend $7 for a handheld meter at HD or Radio Shack or Walmart.
|
05-17-2014, 06:33 PM | #6 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: state of charge meter reading wrong?
What year cart?. Sounds like you have a Series Drive system?? but if you don't and it's a DCS drive system it will have a TOW/RUN switch on the controller cover under the seat, flip the switch to TOW before you disconnect any wires
|
05-17-2014, 10:11 PM | #7 |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: state of charge meter reading wrong?
If you don't have a test voltmeter you can't do much troubleshooting. Better off taking cart to a shop.
|
05-18-2014, 07:04 AM | #8 |
Not Yet Wild
Join Date: Jun 2013
Posts: 32
|
Re: state of charge meter reading wrong?
I'm confused as to why a 5amp charger wouldn't work. Wouldn't it just be like a trickle charger and take a long time?
|
05-18-2014, 07:26 AM | #9 |
Gone Wild
Join Date: Sep 2012
Location: Savannah, GA
Posts: 2,760
|
Re: state of charge meter reading wrong?
To put it simple, 5 amps doesn't have enough grunt to knock off the build-up on the lead plates. You need the higher 18-20A current for that.
|
05-18-2014, 08:17 AM | #10 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: state of charge meter reading wrong?
Go to the carts unlimited website and read every page with the word 'battery' in it. The information is there to help people understand how batteries work, how recharging works, and what is required for long battery life.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
TXT 36 v state of charge meter | Electric EZGO | |||
State of Charge meter keeps going down | Electric Club Car | |||
correctly reading an analog state of charge meter | Electric EZGO | |||
State of Charge Meter...Which One? | Electric EZGO | |||
State of Charge Meter Help? | Electric EZGO |