05-17-2017, 01:59 PM | #1 |
Not Yet Wild
Join Date: May 2017
Posts: 2
|
Runs on choke only
I have a Club Car DS (I think it's a '98 )
. It was running great until I was using it to pull around a couple of cattle panels then I parked it over night, went to get on it the next morning and now it will not run unless I work the choke. It will start on full choke but once it's running I have to work the choke (most of the time it's around 1/2) to keep it running. Here's what I've done. New fuel lines & fuel pump vacuum line, new fuel pump & filters, new carb, pulled the draw straw & cleaned, new air filter, checked the air box & passage way, checked the air tube, valve job (compression is 150+psi), new spark plug. When I'm choking it the air tube going from the air box to the carb does suck shut about 1/2 way. Idk what else to do...I kinda wondered if the new carb isn't adjusted right or is defective. I'm unsure on how to adjust it properly. Thanks for looking and any help you can provide! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-21-2017, 01:21 PM | #2 |
Gone Wild
Join Date: Aug 2014
Location: Akron, Ohio
Posts: 189
|
Re: Runs on choke only
Did you use new carb gaskets?
|
05-29-2017, 11:58 AM | #3 |
Not Yet Wild
Join Date: May 2017
Posts: 2
|
Re: Runs on choke only
I finally got the time to replace the carb gaskets, that didn't change anything. Like I stated before I wondered about the new carb adjustment. I looked at the old carb compared to the new one. I noticed one adjustment screw (on the side up close to the engine) was way in on the old one and way out on the new one. I turned that in, put a brick on the pedal so I could work the choke and adjust the screw. Sure enough I screwed that in all the way and she runs now. She never smoked before but now she is. Idk if it'll clear up or not. Wondering if I may have to tear her down and put some rings in???
|
|
|
Similar Threads | ||||
Thread | Forum | |||
only runs with choke | Gas Yamaha | |||
only runs with choke on | Gas EZGO | |||
G14 runs well only with choke | Gas Yamaha | |||
Runs best with choke on | Gas Yamaha |