|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-10-2022, 01:17 PM | #1 |
Not Yet Wild
Join Date: Jun 2022
Posts: 4
|
Ez go 2five won't show battery and reverse buzz dies out
Hello,
I bought an ez go 2five 2010 not running and was told all it needed was batteries and new brake calipers. We have put new batteries in it and it still won't run. When we flip the key the screen comes on and the reverse buzz comes on even when it is flipped to forward but the batteries show dead on the screen even though they have full battery, and the reverse buzz dies out like it is losing power. We have replaced the motor brake and the solenoid (got a new solinoid for newer carts not sure if that makes a difference). We do not know what the problem is. We are hoping it is just something electrical. We have been following the manual for putting parts on. Please help any advice is great! We got a multi meter power tester but we don't really know how to use it or where to test. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-11-2022, 06:54 AM | #2 |
Gone Wild
Join Date: Sep 2021
Location: Pa
Posts: 279
|
Re: Ez go 2five won't show battery and reverse buzz dies out
I'd start with the wiring harness. The early units had issues with corrosion at the connectors and sonic welds. Best way to inspect it is to remove the body, dash and floor. That way the harness can be pulled out for inspection. If that's not possible, pull the batteries and remove the plastic loom protecting the harness. You'll see three sonic welds (wire connection points), these are common places for corrosion. The red one is the 48V side and the orange is the 5 volt logic side. A poor connection there would cause your problems.
You said it needed new brake calipers ? Do you mean the motor brake ? What is the coil voltage of the solenoid you installed ? That year should use a 36V one. |
06-11-2022, 06:59 AM | #3 |
Gone Wild
Join Date: Sep 2021
Location: Pa
Posts: 279
|
Re: Ez go 2five won't show battery and reverse buzz dies out
You may be better off sending it out for repair. You really need to understand electronic circuits to service those carts. They are not like any DC carts out there. One little slip of a meter lead or a misplaced probe will take out the controller.
|
06-11-2022, 07:48 AM | #4 |
Gone Wild
Join Date: Sep 2020
Location: Germany
Posts: 2,000
|
Re: Ez go 2five won't show battery and reverse buzz dies out
I fully agree with cartdog, you'll need a minimum of understanding what you're doing or it can be expensive.
P.s The 2five is an official LSV cart and has as far as i know additional hydraulic brakes. |
Tags |
2five, cart, ezgo, golf cart, rxv |
|
|
Similar Threads | ||||
Thread | Forum | |||
Kingpin tube and washer for late model 2Five same as earlier 2Five??? | Electric EZGO | |||
2005 ez go will not move or buzz in reverse | Electric EZGO | |||
Txt dies in fwd but not reverse | Electric EZGO | |||
ezgo problem go in reverse, dies in forward, battery bubbling | Electric EZGO | |||
Dies in reverse | Gas Club Car |