|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-19-2022, 04:02 PM | #1 |
Gone Wild
Join Date: May 2018
Location: Killeen, Texas
Posts: 212
|
2018 EZ GO TXT Valor Gas starting issue.....maybe
I play a ton of golf and lately when I hop on and hit the gas pedal, it doesn't immediately start....sometimes. In my mind, maybe I am expecting too much too fast, but if I hold the pedal full down, it will start after I get to a thousand three. Feathering also finds a sweet spot and it will start, again...sometimes. The cart may work absolutely fine for a few holes. All the reading I do points to the stop switch. Tomorrow I will get underneath and apply some pressurized air to the area in an attempt to alleviate possible debris that has accumulated in that area. I have only found one video online and that is for a 2014 RXV. My assumption is the two carts are close. In the five years I have owned this cart, bought new, it has worked wonderfully, except for the hub issue, but that's peculiar to EZGO and since replacement and torque checking, no issues. I wonder if someone out there has had this or maybe my tin foil hat needs adjusting......thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-19-2022, 04:24 PM | #2 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,188
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Problem could be the engine stop solenoid.. It shorts the ignition circuit when you take your foot off the pedal. If you can take an extra spark plug with you and next time it happens put it in neutral and pull the spark plug boot, put the extra plug in the boot and lay it on the block then push the pedal to look for spark. If none replace the solenoid.. Part number 603282
|
12-19-2022, 06:06 PM | #3 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Is it hesitating before turning over, or spinning, but not starting?
If it's hesitating, I would clean both battery cables, and do a load test on the battery. |
12-20-2022, 09:06 AM | #4 |
Gone Wild
Join Date: May 2018
Location: Killeen, Texas
Posts: 212
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Sometimes it runs fine for a good bit. Battery terminals spotless. Battery is almost 5 years old but is still strong. I was a helicopter mechanic in the Army for 20 years then 5 years as a contractor. Super OCD, wound tight and uber meticulous maintaining everything. Thank you though....
|
12-20-2022, 09:08 AM | #5 | |
Gone Wild
Join Date: May 2018
Location: Killeen, Texas
Posts: 212
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Quote:
|
|
12-22-2022, 08:08 AM | #6 |
Gone Wild
Join Date: May 2018
Location: Killeen, Texas
Posts: 212
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Went out removed the cover, after removing the air hose. The area was full of dirt, grass etc. Cleaned it out real well. Got a good spark, couldn't duplicate the issue. I also didn't have time to play golf so it was just putting around in the cart to try and replicate the issue. I ordered a relay anyway, 45 dollars shipped. Probably be easier to replace by removing the battery as well. I don't expect things to last forever. It's all good. One interesting thing is that I am working out of a cart parts manual dated 2010. I have the Kawasaki engine and different clutches, so I know my belt is different and there is no pedal switch.
|
12-22-2022, 10:35 AM | #7 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,188
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Should have the team clutches with the Kawasaki and being a 2018. Ezgo tends to make it a challenge sometimes to find part numbers but it’s possible.. I found the part number I gave you here.. https://www.countrycat.com/arctic-ca...HAULER_1200X/y
|
12-27-2022, 08:05 AM | #8 |
Gone Wild
Join Date: May 2018
Location: Killeen, Texas
Posts: 212
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Relay replaced. Removing the battery made it super easy. Much better now. The battery will be 5 years old in March, will replace that when I do the spring tune up. I am curious what the unconnected extra lead is for under the battery cover. I assume it is an accessory power outlet of some sort. Thank you again for the help. Greatly appreciated.
|
12-29-2022, 04:02 PM | #9 |
Gone Wild
Join Date: May 2018
Location: Killeen, Texas
Posts: 212
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Replaced the battery well just because. It will be 5 years old in March. I flipped the cart on its side a couple of years ago and we were stuck on our side for a few minutes until help arrived. Got a Duracell for 81 bucks with tax. Had to reroute a couple of cables/wires for cleanliness sake and used a cedar shim as the battery is a bit smaller than the original. We played 27 holes today and it ran like a champ the whole time. Life is good.
|
12-29-2022, 04:07 PM | #10 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,188
|
Re: 2018 EZ GO TXT Valor Gas starting issue.....maybe
Cart probably had a 26R in it from the factory. A 24 series will fit with a few mods. My workhorse had a 31 series for years. Had a bunch of lights and could never kill that one.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2018 TXT Valor steep hill issues | Gas EZGO | |||
looking for more speed 2018 valor | Gas EZGO | |||
2018 EZGO Valor wheels and tires? | Gas EZGO | |||
2018 ezgo valor wiring | Gas EZGO | |||
2018 ezgo valor wiring? | Electric EZGO |