08-06-2017, 11:53 AM | #31 |
Not Yet Wild
Join Date: Jul 2017
Posts: 37
|
Re: 1988 Columbia Car Par questions
Well I put the new carburetor on and it ran a lot better but it is still not right.
Choke has to be partially on for it to run and it still does not pull very hard but does go up a hill easier. The new carb has gas running out of the overflow hose slightly. Whats the best way to get the old seals out and new ones in? I have a seal puller |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-06-2017, 03:13 PM | #32 |
Not Yet Wild
Join Date: Jul 2017
Posts: 37
|
Re: 1988 Columbia Car Par questions
Got the engine out right now.
Can't get the nut off that holds the fan assembly on. Been smacking at it with a hammer for 10 minutes. Also can't get the primary inner pulley off the crankshaft. Contemplating a motor swap and go cart axle... |
08-06-2017, 07:40 PM | #33 |
Not Yet Wild
Join Date: Jul 2017
Posts: 37
|
Re: 1988 Columbia Car Par questions
Motor is currently torn down to where the seals can be replaced. Thanks to my Uncle and a propane torch. That fan holder 32mm nut (size not exact) was stuck on there. Used the rope trick to jam the piston.
I got the rubber seal out now and have to drill a hole in the metal one for the fan to get it out. To dark outside now. Will update as I reinstall the motor. |
08-07-2017, 06:52 PM | #34 |
Not Yet Wild
Join Date: Jul 2017
Posts: 37
|
Re: 1988 Columbia Car Par questions
The motor is reinstalled with new crank seals and its still running the same as before. Sputtering and wont move a load well. New carb too.
Going to part this stupid cart out if anyone needs stuff. I'm done with it. |
08-08-2017, 04:55 PM | #35 |
Not Yet Wild
Join Date: Aug 2013
Location: beaver falls, pa
Posts: 21
|
Re: 1988 Columbia Car Par questions
Just make sure the air filter is clean if it's to rich. If it's lean try turning it. 3/4 of a turn I believe. Or check for holes in the intake. IS IT RUNNING RICH OR LEAN?
|
08-08-2017, 10:19 PM | #36 |
Not Yet Wild
Join Date: Jul 2017
Posts: 37
|
Re: 1988 Columbia Car Par questions
Don't care anymore SOLD the cart got my cash back.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
1988 columbia par car carb help | Gas Columbia ParCar | |||
1988 columbia on ebay | Gas Columbia ParCar | |||
1988 columbia par car, | Golf Carts and Parts | |||
1988 Columbia par car | Gas Columbia ParCar | |||
1988 Four Wheel Gas Columbia | Gas Columbia ParCar |