|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
07-25-2014, 07:02 PM | #1 |
Getting Wild
Join Date: Jul 2009
Posts: 76
|
2010 yamaha golf cart smoking
I have 2010 yamaha that just started smoking, just wondering if there is something I should look at before I pull the engine out, im thinking rings, or valve guides.just wondering if there might be something else.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-26-2014, 02:28 AM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2010 yamaha golf cart smoking
Look for very HIGH oil level in the engine, i know, sounds dumb. A stuck needle valve in the carb, or crap gas that is not totally burning will cause over full oil. With no where else to go, the extra "oil" crud will end up going through the top-end, into the airbox, and back into the carb inlet, (unintentionally) to be sent back through the engine and burn. Look in the airbox, on the carb side, the small squares on the floor of the airbox will all be full of oily stuff.
|
07-26-2014, 02:30 AM | #3 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2010 yamaha golf cart smoking
Clean everything out, and do a oil change. Try again, it might clear up. Check fuel condition. If it goes away for a while, then comes back, you have carb needle/junk fuel problems for sure.
|
07-26-2014, 04:33 AM | #4 |
Getting Wild
Join Date: Jul 2009
Posts: 76
|
Re: 2010 yamaha golf cart smoking
Thanks. I have checked breather tube and air box everything clean, so I gues the engine has to come apart. Thanks again.
|
07-26-2014, 10:48 AM | #5 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2010 yamaha golf cart smoking
Have you been using any thing other than OEM filters? Black foam around edge of filter = junk aftermarket, real yamaha ones are ONLY blue, or correct for ydra orange. Aftermarket filters have lower quality foam seal, and often leak.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2010 Yamaha 48v golf cart reverse buzzer always on | Electric Yamaha | |||
2010 ST400 E-Z-GO Gas Golf Cart | Gas EZGO | |||
2010 Star Golf Cart For sale. 48 Volt Street Legal | Golf Carts and Parts | |||
1981 Ezgo Golf Cart Starter/Generator Smoking | Gas EZGO | |||
My 1st Golf Cart!!! 2010 EZGO Express ST | Members Rides |