|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-13-2014, 09:53 PM | #1 |
Not Yet Wild
Join Date: Jul 2014
Posts: 11
|
2000 ezgo cart, no run solenoid clicks
I am new to site , I recently purchased a 2000 ezgo cart I believe a txt
It has brand new fully charged batteries, it ran great for about Two minutes then quit, solenoid clicks but seems to fall out almost Immediately, I left it for a short time and jacked up rear axle Solenoid clicked it ran and then dropped out again Does this indicate a bad solenoid ? Batteries read 38.2v and don't seem to dropped under load . Any help would be greatly appreciated This site send to be the go to place Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-13-2014, 10:05 PM | #2 |
Not Yet Wild
Join Date: Jul 2014
Posts: 11
|
Re: 2000 ezgo cart, no run solenoid clicks
Sorry I posted in wrong place hello
|
07-14-2014, 05:41 AM | #3 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 2000 ezgo cart, no run solenoid clicks
Moved to ezgo forum
|
07-14-2014, 05:51 AM | #4 |
Gone Mad
Join Date: Oct 2009
Location: Buford, GA
Posts: 8,988
|
Re: 2000 ezgo cart, no run solenoid clicks
Tell us which drive system you have.
Controller/Motor Type: http://www.buggiesgonewild.com/attac...go-guide-2.jpg http://www.buggiesgonewild.com/elect...en-system.html |
07-14-2014, 06:05 AM | #5 |
Not Yet Wild
Join Date: Jul 2014
Posts: 11
|
Re: 2000 ezgo cart, no run solenoid clicks
Do I need to move this to ezgo forum?
It has the PDS system |
07-14-2014, 06:14 AM | #6 |
Gone Mad
Join Date: Oct 2009
Location: Buford, GA
Posts: 8,988
|
Re: 2000 ezgo cart, no run solenoid clicks
You're in the right place now.
http://www.buggiesgonewild.com/electric-ezgo/ Specifically: http://www.buggiesgonewild.com/elect...id-clicks.html |
07-14-2014, 09:20 AM | #7 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 2000 ezgo cart, no run solenoid clicks
Solenoid is probably okay.
The controller controls the solenoid in a PDS cart, so either the controller is bad, or something is telling it to de-energize the solenoid. The wires highlighted in red on the attached schematic have to have battery pack voltage on them for the controller to keep the solenoid energized. but if you loose the voltage on any of them, the beeper sounds and the controller turns on max regen braking. Try driving cart with controller in diagnostic mode. It might give you an error code when the cart misbehaves. The text at the bottom of attached label, tells you how to put controller into diagnostic mode. |
07-14-2014, 01:06 PM | #8 |
Not Yet Wild
Join Date: Jul 2014
Posts: 11
|
Re: 2000 ezgo cart, no run solenoid clicks
Thanks for reply, cart doesn't move so I can't drive
In diag mode, could it be a resistor fault I read online That if voltage across solenoid big terminals isn't at least 3v difference it's a resistor fault ? Is it common for controller to Have intermittent fault ? |
07-14-2014, 09:06 PM | #9 |
Not Yet Wild
Join Date: Jul 2014
Posts: 11
|
Re: 2000 ezgo cart, no run solenoid clicks
After finally getting cart into diag mode the bleep
Codes were 3-2 I believe this to be solenoid welded Is this a symtom of a bad controller or is this a common fault? Help appreciated |
07-15-2014, 06:13 AM | #10 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 2000 ezgo cart, no run solenoid clicks
Error code 3-2. Check the voltage on J1 Pins 4 & 5.
Should be full battery pack voltage. If it isn't, it may be causing the 3-2 code. If the voltage on the solenoid's controller side large terminal is the same when the solenoid is energized and de-energized, the contacts are welded. |
|
|
Similar Threads | ||||
Thread | Forum | |||
Solenoid Clicks but cart doesn't go... | Electric EZGO | |||
Solenoid Clicks and Controller Flashes 7 times then solid green but no go. 2000 CC DS | Electric Club Car | |||
1995 ezgo solenoid clicks but cart won't move | Electric EZGO | |||
my 2000 clubcar ds solenoid clicks when i turn key switch on whats happening? | Electric Club Car | |||
90 ez go solenoid clicks but cart won't go | Electric EZGO |