|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-29-2020, 09:38 PM | #1 |
Gone Wild
Join Date: Aug 2018
Posts: 163
|
Light sputter/jerking.... ONLY on initial movement
Here's the issue specs.
2008 Club Car Precedent 4-12v US batteries 2017 date codes and they all test out fine. Cart seems to sputter a bit or be slightly "jerky" only when lightly accellerating or going in reverse. It seems to only do this as the pedal is lightly depressed as it doe snot seem to miss a beat when cruising around. Does this sound like a MCOR issue or a speed sensor issue? Just looking for a bit of advice on where to start. BTW the feeling is more of a shudder than a jerk. It is mild but noticable. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-29-2020, 11:23 PM | #2 |
MOD of all BS!
Join Date: Sep 2011
Location: Florida
Posts: 17,477
|
Re: Light sputter/jerking.... ONLY on initial movement
That is almost always a bad MCOR. https://www.revolutiongolfcars.com/mcors
|
03-29-2020, 11:43 PM | #3 |
Gone Wild
Join Date: Aug 2018
Posts: 163
|
Re: Light sputter/jerking.... ONLY on initial movement
I lurk around this forum all the time..... Your opinion is highly regarded and appreciated NoleFan!
I will start there. Thank You |
03-30-2020, 07:43 AM | #4 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,005
|
Re: Light sputter/jerking.... ONLY on initial movement
Just for something to try, put it in N key off and pump the go pedal 20-30 times. If it helps bad mcor
|
03-30-2020, 10:06 AM | #5 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Light sputter/jerking.... ONLY on initial movement
Could be worn out brushes in the motor. Not terribly difficult to replace, but the only way to check them is to take the motor apart.
|
03-31-2020, 03:36 AM | #6 |
Gone Wild
Join Date: Aug 2018
Posts: 163
|
Re: Light sputter/jerking.... ONLY on initial movement
KGSC- I tried pumping the gas about 40 times like you mentioned and then flipped the switch to both forward and reverse. Crept forward and backward with no stutter/jerking. looks like Nolefan was onto my problem being the MCOR. Thanks for the tip! hopefully a new one fixes the issue.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Club car sputter at low speed | Gas Club Car | |||
I sputter when half tanked! | Gas Club Car | |||
G16 sputter& die | Gas Yamaha | |||
Low speed workhorse sputter | Gas EZGO | |||
engine sputter after lift? | Lifted Golf Carts |