lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 06-15-2008, 11:28 PM   #1
Carsfred
Not Yet Wild
 
Join Date: Jun 2008
Posts: 2
Default 91 Ez GO CUTS OUT AT 3/4 THROTTLE

HAVE JUST BOUGHT A 91 EZ-GO 36 VOLT GOLF CART. HAD TO REPLACE 4 OUT OF SIX BATTERIES AND GOLF CART RUNS GREAT BUT AT 3/4 TO FULL THROTTLE IT ACTS AS IF YOU SHUT KEY OFF. ANY IDEAS? Works good in reverse. Is there a high speed mode that may not be working?
Carsfred is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 06-16-2008, 08:10 AM   #2
pggroves
steeplejack x
 
pggroves's Avatar
E-Z-GO
 
Join Date: Jan 2007
Location: Republic of Texas
Posts: 3,382
Default Re: 91 Ez GO CUTS OUT AT 3/4 THROTTLE

Which type of electrical system? Is it a resistor setup or does it have an electronic speed controller?
pggroves is offline   Reply With Quote
Old 06-16-2008, 10:45 PM   #3
Carsfred
Not Yet Wild
 
Join Date: Jun 2008
Posts: 2
Default Re: 91 Ez GO CUTS OUT AT 3/4 THROTTLE

Cart has electronic speed controller.
Carsfred is offline   Reply With Quote
Old 06-17-2008, 06:34 AM   #4
roady89
nimda
Club Car
 
Join Date: Jun 2007
Posts: 13,022
Default Re: 91 Ez GO CUTS OUT AT 3/4 THROTTLE

The throttle for that model uses a potentiometer that runs from 0-5k ohms. 0 ohms being 0% throtle ans 5k being 100% throttle. Sounds like either your throttle pot (PB-6) is either going out of range or is just bad. You will need a volt/ohm meter to check it. Place the meter on ohms and probe the 2 signal wires.


Second theory. Check your F/R switch contacts. You may be losing connection when the cart gets under load.

There is no "high speed mode" to speak of. Only 100% throttle.
roady89 is offline   Reply With Quote
Old 07-19-2008, 10:20 PM   #5
cpgolez
Not Yet Wild
 
Join Date: Nov 2007
Location: Philippines
Posts: 8
Default Re: 91 Ez GO CUTS OUT AT 3/4 THROTTLE

I have a similar problem.. when you press the pedal, it just clicks but doesn't run so you release a little bit and it goes but the speed is jumpy, not smooth at all. I bought a new potentiometer because i was told by my a mechanic that the pot was busted. It still doesn't go...
cpgolez is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
touchy throttle Gas Club Car
Charger cuts off after 5 mins? Electric Club Car
Throttle adjustment Big Block Talk!
Throttle problem? Electric Club Car
throttle is sticking Electric EZGO


All times are GMT -5. The time now is 12:07 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.