lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 08-23-2023, 09:05 AM   #81
rose88
Gone Wild
 
rose88's Avatar
Club Car
 
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,266
Default Re: Lockman1's DS idle setup?

Quote:
Originally Posted by lockman1 View Post
It's really simple! and It's not my idea... Tom @ CPP told me about it!

(Note: I don't know if this works for PRE-1992 DS Club Cars!)

Put your cart in maintenance mode, chock the wheels... and the key off!

In the engine compartment, There is a black plastic box, just below the drivers seat!

Remove the one hex screw, and then the cover for the box,
You'll see the voltage regulator, solenoid, two micro switches, a single 10 amp fuse, and a bunch of wires!

Go to the micro switches... wipe the dirt off of the micro switch wires (without disconnecting them)

There should be only one solid black wire...
(I think it's on the bottom micro switch)

Disconnect the solid black wire ONLY! (pedal kill circuit)
and set the wire off to the side, (inside the box) and reinstall the cover!



You are now ready to adjust your idle!

Again... with the cart in maintenance mode, and the wheels chocked,
Turn the key on, push the "GO" pedal to start it...
and adjust your idle up just high enough so the drive belt is just about ready to turn
(if the drive belt turns too much, the cart will "creep" while idling!)

Turn the key off to shut it down, set the brake,
take the cart out of maintenance mode, and remove the wheel chocks.

Test drive (start and stop) to make sure it won't stall or creep... and adjust the idle if needed!

Your cart will now start with the pedal... idle... and shut off with the key!


So how would you do this in reverse from key start to pedal start? Carryall 272 FE400
rose88 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Reply

Tags
idle, idle fix, idle mod
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G9 idle mod Gas Yamaha
Club Car Villager 6 modified to idle; Starter-Gen not recharging battery at idle? Gas Club Car
G14 will not idle Gas Yamaha
How do I idle Gas Yamaha


All times are GMT -5. The time now is 03:25 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.