lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 10-10-2012, 06:55 PM   #1
danno5069
Not Yet Wild
 
Join Date: Oct 2012
Posts: 1
Default EZ-GO Total Charge 2

Power comes on, display reads 3 flashing zeros and 1 stationary zero wth period beside it left to right, no humming sound from unit.
Any ideas
danno5069 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-11-2012, 08:11 AM   #2
JohnnieB
Techno-Nerd
 
JohnnieB's Avatar
E-Z-GO
 
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
Default Re: EZ-GO Total Charge 2

Sounds like the numeric display is lighting up, but the charger itself isn't turning on.

Could be:
a. Battery pack voltage too low to turn charger on
b. Open wire, connection or component in charging loop.
c. Control board is bad.

I'm not 100% sure of this, but if you press the bottom button on left side, it should show you the voltage being sensed by the control board.

If it shows a voltage less than about 30V, you'll have to charger the batteries in pairs with a 12V charger to get the voltage up high enough to turn on the 36V TC-II charger.

If it shows no voltage at all, Check the voltage on the two terminals in the cart's charger receptacle.
If you have over 30V there, check the voltage going to the control board inside the charger. (The black wire coming from the ammeter and the red wire coming from the heatsink)
It you've got over 30V there, the control board is probably bad.

Here is a manual for a TC-II, there is a schematic inside.
Attached Files
File Type: pdf TC-II, 36 & 24 volt,1989,25436-G1RS.pdf (3.36 MB, 0 views)
JohnnieB is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
Total Charge 3 Golf Carts and Parts
Total Charge II Charger Electric EZGO
Total Charge question Electric EZGO
Ez Go Total Charge 3 Charger Golf Carts and Parts
Looking for Total Charge III Golf Carts and Parts


All times are GMT -5. The time now is 03:42 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.