lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 09-06-2021, 01:42 PM   #1
Alby
Not Yet Wild
Club Car
 
Join Date: Jun 2021
Location: Kingsbury, TX
Posts: 37
Default 1995 Club Car Carryall 1 CARB ISSUE?

Cart was running fine 4 weeks ago. Went to go use it and it barely runs, acts like its starving for fuel. Pulled carb. cleaned jets, float needle seats fine. There were some small particles in gas tank but filter would catch them. Fuel pump working as it was. Compression is 152 before anyone asks LOL. It ran good for 3 minutes after cleaning carb and went back to barely running. Been messing with it for 4 hours and am at a loss!!!! It did this one time before, but there was crap in the jets, however there isnt anything this time. Any advice??? Thanks
Alby is offline   Reply With Quote
Old 09-06-2021, 03:31 PM   #2
Scott quail
Gone Wild
 
Join Date: May 2021
Posts: 289
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

Are you actually getting fuel to the carb from the pump?
Scott quail is offline   Reply With Quote
Old 09-06-2021, 05:01 PM   #3
Alby
Not Yet Wild
Club Car
 
Join Date: Jun 2021
Location: Kingsbury, TX
Posts: 37
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

Yes I am getting fuel to carb. I forgot to add I pulled the spark plug and was pretty black and not wet. Cleaned it an re installed but no change.
Alby is offline   Reply With Quote
Old 09-06-2021, 06:44 PM   #4
Scott quail
Gone Wild
 
Join Date: May 2021
Posts: 289
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

Check for spark. Does it run with spray? If you are getting fuel to the carb and you know you have good fire then your issue may be the carb. How is your gas? Old, new? A dirty plug is also a sign of good fire and bad gas.
Scott quail is offline   Reply With Quote
Old 09-07-2021, 11:33 AM   #5
Alby
Not Yet Wild
Club Car
 
Join Date: Jun 2021
Location: Kingsbury, TX
Posts: 37
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

The engine starts right up however when you get on it to go full speed it will not. it is bogging down. Gas is not old but who knows, could have gotten condensation in tank. Ill drain fuel and add. I'm just stumped! Was running fine before i parked it for a month!!!
Alby is offline   Reply With Quote
Old 09-07-2021, 11:39 AM   #6
crash12888
Gone Crazy
 
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

Check the carb vent tube or if it is gone the carb vent nipple for mud dobber
crash12888 is offline   Reply With Quote
Old 09-08-2021, 04:09 PM   #7
Alby
Not Yet Wild
Club Car
 
Join Date: Jun 2021
Location: Kingsbury, TX
Posts: 37
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

Problem solved!!! The pick up tube in gas tank had a crack in it. Was no fun to fix. Got her running like a champ-for now!!!! Thanks guys
Attached Images
File Type: jpg cart.jpg (154.6 KB, 0 views)
Alby is offline   Reply With Quote
Old 10-11-2021, 02:54 PM   #8
Alby
Not Yet Wild
Club Car
 
Join Date: Jun 2021
Location: Kingsbury, TX
Posts: 37
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

Here we go again!!! I am at a loss. Cart ran for a week and then stopped again. I put a new carb on it too. Now where do I check? i haven't replace fuel pump yet. Any help would be appreciated before I start it on fire! LOL
Alby is offline   Reply With Quote
Old 10-12-2021, 03:52 PM   #9
Alby
Not Yet Wild
Club Car
 
Join Date: Jun 2021
Location: Kingsbury, TX
Posts: 37
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

I re-pulled the pick up tube- no leaks. I pulled pulse line off pump and yes its pumping. Hooked pulse line back up, disconnected hose from pump to carb- nothing pumping out! So a bad pump?
Alby is offline   Reply With Quote
Old 10-13-2021, 06:48 AM   #10
crash12888
Gone Crazy
 
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
Default Re: 1995 Club Car Carryall 1 CARB ISSUE?

sounds like it, I've had fuel pumps sit for a while and I guess get dry inside and not pick up fuel.
I've blown a bit of air in the tank and forced some fuel through the system to get it "primed" and wet.
That might get it started and work, if it still drops off time for a new pump.
Any of the pulse pumps from briggs or lawn and garden engines will work, doesn't have to be the pricey OEM.
crash12888 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
1995 Club Car Carryall 1 wiring issue Gas Club Car
1995 club car carryall- gas Gas Club Car
Wanted: Headlight for 1995 Club Car Carryall Golf Carts and Parts


All times are GMT -5. The time now is 11:41 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.