|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-14-2010, 05:03 PM | #1 |
Not Yet Wild
Join Date: May 2010
Posts: 19
|
Where is the pulsar soil located? on a 81
Where is the pulsar soil located? Looks like its in the engine? Hard to change? If i need to?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-14-2010, 05:14 PM | #2 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: Where is the pulsar soil located? on a 81
On my 86 it is behind the harmonic balancer. You will need to remove the fan cover and then the fan. Now you will need to use a puller to remove the balancer and then you can see the pulsar. I took my engine out so the hardest part of the job was to get a puller to fit. If you suspect the pulsar you should use an ohmeter between the blue and red wires and you should see between 75 and 140 ohms.
|
06-14-2010, 06:27 PM | #3 |
Not Yet Wild
Join Date: Jun 2010
Location: Columbus,Ga
Posts: 37
|
Re: Where is the pulsar soil located? on a 81
Still new to this but your model may have points? If it has the pulsar, it is behind the flywheel. It might be easer to remove the engine to replace it. After removing the engine in my 87, a few times, It could be done in about 30-45 min. and replaced in about the same. This would be a good time to replace the crankshaft seals. You will be right there when you remove the pulsar(make sure to mark the location since it is in a slot). Make a clutch removing tool from 5/8th threaded rod and a 3/4 inch NFT bolt 2 inches long. Got mine at Tractor supply. The seals were about $3.00 each. Now is the time.
Mike |
06-14-2010, 07:43 PM | #4 |
Not Yet Wild
Join Date: May 2010
Posts: 19
|
Re: Where is the pulsar soil located? on a 81
Thanks guys. Mine is within specs.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
EZ-GO ST480 Workhorse Cart-Gas,located in Jacksonville,Fla | Golf Carts and Parts | |||
where is the serial number located? | Electric Club Car | |||
Pulsar cable/wire | Gas EZGO | |||
Pulsar coil | Gas EZGO | |||
Where is back up buzzer located on 2003? | Electric EZGO |