lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 04-18-2018, 12:10 PM   #1
nsudemon46
Not Yet Wild
 
Join Date: Jul 2017
Posts: 26
Default 2006 Yamaha G22E Runs in Foward but no Reverse

I have a 2006 Yamaha G22E the cart was an old cart from a golf course. No Batteries, Controller, or Solenoid when I got it. I have since purchased Duracell batteries, Tombetta 48v solenoid from Red Hawk, and a used OEM GE Controller. I tested the motor by jumping wires from A1/F1 and A2/F2 and connecting 12volts to it. The motor turned the tires. I have since went through the wiring harness to make sure all wires were good. Fixed a couple of bare wires that were exposed. Got all the wires connected up to the batteries, controller, and solenoid. Turn the tow/Run to Run turn the key I get a click from the solenoid, press the pedal and it will run in forward. If I turn the F/R switch to reverse the solenoid will click when I press the pedal but nothing happens. No reverse buzzer sound when in reverse and key on or reverse buzzer sound when key off and in reverse. To get the cart going forward again I have to turn the key off and turn the Tow/Run to tow for about 15 seconds and then I can turn the F/R to Forward key on and moves forward again. Any help on what I can test to determine if it is a controller issue or a motor issue or even I wiring issue. I have looked at the wiring diagram until I have seen spots lol.

Wires I have ran
Cable from Neg. Battery post to negative post of Controller

Positive cable from positive post to large post of the solenoid

Jumper cable from other large post of solenoid to Positive of Controller.

Wire connector with 3A fuse connected to the large solenoid post with
Positive from battery.

Connector with the black and red wires connected to the small post of the solenoid
Attached Images
File Type: jpg solenoid.jpg (223.2 KB, 0 views)
File Type: jpg controller.jpg (4.9 KB, 0 views)
nsudemon46 is offline   Reply With Quote
 
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
2006 electric EZGO runs only in reverse, help pls Electric EZGO
2006 Yamaha G22e before, after and the future Electric Yamaha
New Yamaha G22e (2006) Owner with issues Electric Yamaha
74 harley 3wheeler runs bad foward Gas Harley Davidson
Cart runs 10mph in foward and 17 in reverse....help Electric EZGO


All times are GMT -5. The time now is 08:48 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.