|
11-03-2009, 05:00 PM | #1 |
Not Yet Wild
Join Date: Sep 2009
Posts: 4
|
Smoke???!!!!
When I drive along after a min it will sputter lose power then clear right up when I look back there is so much white smoke you can't even see thru it.. What's this from??? And how do I fix it?
|
11-03-2009, 09:20 PM | #2 |
Not Yet Wild
Join Date: Oct 2009
Location: Georgetown SC
Posts: 43
|
Re: Smoke???!!!!
Well thats not a whole lot of info but I will try.
Is there smoke at start up? Does the smoke ever clear up? Does it smoke while going up a hill? How does it run over all. Assuming it is a four cycle, have you checked the oil level? If it is overfilled the engine will smoke. Is there a vaccumn hose from the crankcase up to the carb. Try disconnecting it and see what happens. It could be a valve seal or a cracked or broken ring can cause this type of problem. Also a hole in a piston. Hopefully it is just something simple just keep digging and you will figure it out. |
11-03-2009, 09:32 PM | #3 | |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,900
|
Re: Smoke???!!!!
Quote:
I was just alittle more the a quarter over full, and my 07 cart did the same thing! I drained just enough oil to get it just below the full line, and, no more smoke, no more sputter.... problem solved! |
|
11-04-2009, 11:26 AM | #4 |
Not Yet Wild
Join Date: Sep 2009
Posts: 4
|
Re: Smoke???!!!!
It looks a little over full not much at all.. And it has lots of power still runs real good like it always has till it sputters jus for a sec then clears up blows lots of smoke then clears right up and it doesn't smoke any other time
|
11-04-2009, 09:38 PM | #5 | |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,900
|
Re: Smoke???!!!!
Quote:
Do me a favor... Drain just a little out so it's just below the full line, then try it! If it still does it then we'll help you to look elsewhere! a couple of questions though... Is the cart lifted? and, Is the govenor adjusted to a higher RPM? |
|
11-06-2009, 07:00 PM | #6 |
Not Yet Wild
Join Date: Oct 2009
Location: Georgetown SC
Posts: 43
|
Re: Smoke???!!!!
I aggree with Lockman. Just drain all the oil and spend 4 bucks and start over with two new quarts. Fill it about half way between the full and low marks and run it.
Remember that oil thins and expands when hot. You quanity will increase when you have been using it. Good Luck. Eric |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Where there's smoke there is bearing damage | Electric EZGO | |||
Sparks and Smoke | Electric Club Car | |||
A lot of smoke, but no fire. | Electric EZGO | |||
White Smoke | Gas Club Car | |||
Fire, smoke and other stupidity | Electric Club Car |