|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
03-01-2017, 10:07 AM
|
#1 |
|
Not Yet Wild
Join Date: Dec 2016
Location: Virginia
Posts: 17
|
Battery light on 25 seconds off 10 seconds
96 club car DS 48 volt powerdrive new batteries new OBC light still coming on. Any thoughts?? Thanks!!
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
03-01-2017, 10:37 AM
|
#2 |
|
Gone Wild
Join Date: Dec 2016
Location: Alaska/SoCal
Posts: 549
|
Re: Battery light on 25 seconds off 10 seconds
Possible the Charger is shutting off before batts get a full charge
Possible to try another charger? Good , clean #10 charger wires, terminals & connections from charger plug to batts? Pack voltage while charging, when charger just shuts off? Charger amp meter reading when charging? |
|
|
|
|
03-01-2017, 11:17 AM
|
#3 |
|
Not Yet Wild
Join Date: Dec 2016
Location: Virginia
Posts: 17
|
Re: Battery light on 25 seconds off 10 seconds
Ok I'll try another charger. I thought OBC turned charger on and off. 66 volts while charging.52 volts one hour after. All cables are new. 10 guage wires and connectors good. Thanks for quick response!!
|
|
|
|
|
03-01-2017, 11:18 AM
|
#4 |
|
Not Yet Wild
Join Date: Dec 2016
Location: Virginia
Posts: 17
|
Re: Battery light on 25 seconds off 10 seconds
Maybe new batteries not up to full charge yet
|
|
|
|
|
03-01-2017, 11:29 AM
|
#5 |
|
Gone Wild
 Join Date: Jun 2014
Location: Green Valley, Az
Posts: 678
|
Re: Battery light on 25 seconds off 10 seconds
Reset OBC by removing neg. cable for 10 min. and then recharge...should stop the battery light from coming on unless you have added something that has by-passed the OBC.😎
|
|
|
|
|
03-01-2017, 11:38 AM
|
#6 |
|
Not Yet Wild
Join Date: Dec 2016
Location: Virginia
Posts: 17
|
Re: Battery light on 25 seconds off 10 seconds
Ok thanks Boss I haven't reset OBC. No I'm not bypassing OBC. Already been down that road. That's why I have new batteries and new OBC!
|
|
|
|
|
03-01-2017, 01:30 PM
|
#7 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Battery light on 25 seconds off 10 seconds
Make sure you only have a single cable on the Solenoid big post that goes to the Controller B+.
Any other wires on the Solenoid big post should be on the battery side. On the by-pass question, there should also be only a single pack negative cable. |
|
|
|
|
03-01-2017, 03:13 PM
|
#8 |
|
Not Yet Wild
Join Date: Dec 2016
Location: Virginia
Posts: 17
|
Re: Battery light on 25 seconds off 10 seconds
Ok thanks Sergio! So you're saying my negative wires for my voltage reducer and state of charge meter should go to controller B- not #6 negative post
|
|
|
|
|
03-01-2017, 03:18 PM
|
#9 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Battery light on 25 seconds off 10 seconds
Definitely the voltage reducer negative should be on Controller B-.
I was referring to only have one big cable going from the pack negative battery post, passing through the OBC to the controller B-. Sometimes folks upgrade their cables and try to run a second one in parallel with the stock one and around the OBC. |
|
|
|
|
03-01-2017, 03:33 PM
|
#10 |
|
Not Yet Wild
Join Date: Dec 2016
Location: Virginia
Posts: 17
|
Re: Battery light on 25 seconds off 10 seconds
Ok thanks Sergio. I upgraded to#4 guage but I ran it through the OBC. Thanks again for your time and quick response!!��
|
|
|
|
|
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Car runs for few seconds? | Electric Yamaha | |||
| Battery light on 25 seconds off 5 seconds | Electric Club Car | |||
| 2004 Precedent Brake light stays on for 30 seconds | Electric Club Car | |||
| G22 runs 10 seconds | Electric Yamaha | |||
| 0 to 50 in 3 seconds | Electric EZGO | |||
Linear Mode
