|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-24-2016, 04:58 PM | #1 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
02 club car ds electric wont go over 5 mph
Has new Trojans,new computer,now charges and shuts off charger but when I hit pedal it shutters and only goes 5 mph in forward or reverse,batteries load tested good,don't know if I have a bad controller or moor,any help appriciated
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-24-2016, 06:11 PM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Chestermere, Alberta - Canada
Posts: 1,146
|
Re: 02 club car ds electric wont go over 5 mph
Can't tell what drive system you've got (series or sepex)? Shuddering is usually a series behavior caused by low voltage. Advise serial # and / or report drive type by looking HERE.
|
10-25-2016, 04:29 AM | #3 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 02 club car ds electric wont go over 5 mph
It is a series,thanks for reply,was told I need to check moor and controller
|
10-25-2016, 09:26 AM | #4 |
Gone Wild
Join Date: Sep 2012
Location: Chestermere, Alberta - Canada
Posts: 1,146
|
Re: 02 club car ds electric wont go over 5 mph
A series cart that shudders is almost always a power problem. Even though your charger seems to be working, something is starving the motor for power. Check all battery connections for clean and tight.
Then put a DVM on the entire battery pack and start to drive while watching the voltage. I'm betting you will see a large voltage drop when you push the GO pedal. It is not impossible that one of your new batteries is faulty. |
10-25-2016, 06:42 PM | #5 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 02 club car ds electric wont go over 5 mph
Load tested pack and they never dropped below 49.today I removed motor and found brushes were wiped out.thanks for the help
|
10-26-2016, 11:32 AM | #6 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 02 club car ds electric wont go over 5 mph
Put new brushes in motor but problem still there.shutters and goes 5 mph.
I have 51 volts at all motor terminals with key off,51 volts at red wire of controller.any ideas |
10-26-2016, 05:02 PM | #7 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 02 club car ds electric wont go over 5 mph
Locate the three wires on the controller plugged into terminals 1, 2, and 3. Un-plug the yellow and green wires from 2 and 3. With a multimeter set to 20k ohms, insert the leads of the multi meter into the ends of these two wires you unplugged. With the vehicle in FORWARD and the key ON, cycle the accelerator pedal from top to bottom, monitoring the reading on the screen throughout the entire throttle range. You should see approximately 6800 ohms at no throttle and approximately 1100 ohms at full throttle. Post your results and I'll tell you what you need to do next.
|
10-26-2016, 05:11 PM | #8 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 02 club car ds electric wont go over 5 mph
Thank you.i got 766 to 1568
|
10-26-2016, 05:39 PM | #9 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 02 club car ds electric wont go over 5 mph
Definitely incorrect readings. The MCOR is putting out an incorrect throttle signal to your controller, which can definitely explain the slow speeds. The MCOR 4 conversion kit, number AM293101 is what you'll need to get to repair your cart.
|
10-27-2016, 03:08 PM | #10 |
Not Yet Wild
Join Date: Oct 2016
Posts: 73
|
Re: 02 club car ds electric wont go over 5 mph
GOT ANOTHER METER AND DOUBLE CHECKED MY READINGS AND THEY WERE CORRECT.thanks for the help and I ordered part from vendor on this site
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
1984 electric club car wont go! | Electric Club Car | |||
'03 electric club car wont go | Electric Club Car | |||
83 electric club car wont run | Electric Club Car | |||
Electric Club Car wont Go-2 | Electric Club Car | |||
Electric Club Car wont Go!! | Electric Club Car |