lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 10-01-2018, 07:56 AM   #1
mgray70
Gone Wild
 
mgray70's Avatar
E-Z-GO
 
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,534
Default DS IQ new Alltrax fault code.

This cart got flooded a little and the controller was obviously toast when the owner brought it to me. I tested the motor both continuity and with power. Motor ran fine. Installed a new XCT. Cart ran great. Then all of a sudden I'm getting a one green one red code which says open, or short circuit. I removed the motor, cleaned and inspected ( I suspected corrosion or stuck brushes) all looked good. Continuity between A1 and A2, continuity between F1 and F2, open from A to F and open to the casing. Reinstalled the motor, and get the same code. What am I overlooking? I hate to buy a motor if it's good. I'm gonna retest it with power later and see if it runs.
Thanks!

Sent from my SM-G930R4 using Tapatalk
mgray70 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 10-01-2018, 08:34 AM   #2
BBBHC
Gone Wild
 
BBBHC's Avatar
Club Car
 
Join Date: Jul 2018
Location: Central Ohio
Posts: 1,720
Default Re: DS IQ new Alltrax fault code.

Corrosion in wiring other than the motor? Main wiring harness, batteries?
BBBHC is offline   Reply With Quote
Old 10-01-2018, 08:55 AM   #3
mgray70
Gone Wild
 
mgray70's Avatar
E-Z-GO
 
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,534
Default Re: DS IQ new Alltrax fault code.

Quote:
Originally Posted by BBBHC View Post
Corrosion in wiring other than the motor? Main wiring harness, batteries?
The main connector at the controller looks great in fact I don't think it got any water in the controller area. I think what took out the controller was they tried to drive out while it was in the water. I'll check come of the other connectors. The OBC connector looked good as well. Could a bad coil on the solenoid cause this code?

Sent from my SM-G930R4 using Tapatalk
mgray70 is offline   Reply With Quote
Old 10-02-2018, 05:24 PM   #4
mgray70
Gone Wild
 
mgray70's Avatar
E-Z-GO
 
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,534
Default Re: DS IQ new Alltrax fault code.

Can anyone tell me what ohm reading I should get between A1 and A2, and between F1 and F2? I have continuity between them. I check the ohms and get 2.9.


Sent from my SM-G930R4 using Tapatalk
mgray70 is offline   Reply With Quote
Old 10-02-2018, 06:29 PM   #5
mgray70
Gone Wild
 
mgray70's Avatar
E-Z-GO
 
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,534
Default Re: DS IQ new Alltrax fault code.

I removed all the cables from the motor, doublechecked motor continuity. Applied 12 volt to the motor and it runs fine. Hooked the controller back up and left the control lose face up to test and runs fine. Mounted it back and get the same thing. Must be something in the harness, I just have to find it. All looks good.

Sent from my SM-G930R4 using Tapatalk
mgray70 is offline   Reply With Quote
Old 10-02-2018, 08:56 PM   #6
NoleFan4Ever
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 17,477
Default Re: DS IQ new Alltrax fault code.

Quote:
Originally Posted by mgray70 View Post
Can anyone tell me what ohm reading I should get between A1 and A2, and between F1 and F2? I have continuity between them. I check the ohms and get 2.9.
Test between F1 and F2 and you should get 0.8 to 1.2 Ohms for a Sepex motor
NoleFan4Ever is offline   Reply With Quote
Old 10-03-2018, 03:24 PM   #7
mgray70
Gone Wild
 
mgray70's Avatar
E-Z-GO
 
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,534
Default Re: DS IQ new Alltrax fault code.

I just got off the phone with Ron at Alltrax, and after a few test that he had me run, it turns out that the new controller is faulty. He had me to disconnect the M- which takes the motor out of play, and I was still getting the code. They have me another on the way. Great customer service!

Sent from my SM-G930R4 using Tapatalk
mgray70 is offline   Reply With Quote
Old 10-03-2018, 04:00 PM   #8
NoleFan4Ever
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 17,477
Default Re: DS IQ new Alltrax fault code.

Quote:
Originally Posted by mgray70 View Post
I just got off the phone with Ron at Alltrax, and after a few test that he had me run, it turns out that the new controller is faulty. He had me to disconnect the M- which takes the motor out of play, and I was still getting the code. They have me another on the way. Great customer service!
The best in the business and Ron Mann is a terrific guy to work with!
NoleFan4Ever is offline   Reply With Quote
Old 10-03-2018, 04:42 PM   #9
mgray70
Gone Wild
 
mgray70's Avatar
E-Z-GO
 
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,534
Default Re: DS IQ new Alltrax fault code.

Quote:
Originally Posted by NoleFan4Ever View Post
The best in the business and Ron Mann is a terrific guy to work with! [emoji106]
He sure is. I was thinking bad controller, because everything else checked out. I hated to buy Motor and still have the same problem, and that's what would have happened if I hadn't of called them.

Sent from my SM-G930R4 using Tapatalk
mgray70 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
O5 club car fault code 13 Electric Club Car
Fault Code on charger Electric EZGO
pre charge fault code on 98 Nev Electric Club Car
Iq fault code??????? Electric Club Car
Alltrax fault code 5 Electric EZGO


All times are GMT -5. The time now is 12:16 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.