|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-08-2014, 06:48 PM | #1 |
Not Yet Wild
Join Date: Jun 2014
Posts: 13
|
'99 DS, Lacking Oomph
All -
First, congrats on an awesome forum! This isn't a forum that I previously knew existed until I started looking (for a solution the following problem), but man ... what a cool group of dudes. I can only hope to contribute to this awesomeness going forward. My issue is that I have a '99 Club Car DS, purchased about a year ago that has relatively new batteries (Oct 2012, as labeled) but still just is having general sluggishness. It's just losing its spunk. The kind of sluggishness that hasn't left me stranded, but rather certainly wondering "am I going to make it home?". It still persists, but any uphill climb is clearly very taxing to this thing. I just did a voltage test across the batteries, which - if you believe my cheap ebay-purchased battery gauge - is on the low-side at approximately 1/3 of a full charge. Keeping that in mind, at idle (doing absolutely nothing) it shows a voltage of 46.7V. With the rear up on jacks and full throttle (not a real load) it reads 46.0V. Under a real load (going up a hill in my neighborhood) it drops to 43.7V. Doesn't seem like a huge drop, but still somewhat significant. As mentioned, these batteries are not old (~20 months), which seems to rule out the easy-albeit-expensive-fix (new batteries). I have not dug in any deeper yet, as I'm not sure where to go from here. Is there anything else that I can check out, that might be indicative of what this cart's issue is? It is currently charging, just plugged it in. I will repeat the same load/no-load test once it's fully charged, although I'm not sure that it will reveal anything new (a 3V drop under load seems like nothing). Thanks for any help! Brett |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-08-2014, 07:05 PM | #2 |
Guest
Posts: n/a
|
Re: '99 DS, Lacking Oomph
first read !!!! >>> http://www.buggiesgonewild.com/elect...ller-well.html next you need to charge cart till charger shuts off .. then in 12hrs take pack voltage reading and post results then take each battery voltage and post results off the top of my head i guess you have a cell bad in one or more of your batteries oh please post number of batteries when asking for help |
06-08-2014, 07:49 PM | #3 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,125
|
Re: '99 DS, Lacking Oomph
Your voltages are low for charged batteries. Don't ever run the cart with the wheels off the ground! You can very easily destroy the motor.
|
06-08-2014, 07:53 PM | #4 |
Not Yet Wild
Join Date: Jun 2014
Posts: 13
|
Re: '99 DS, Lacking Oomph
[QUOTE=crash test dummy;1038558]first read !!!!Catastrophic motor failure link
[QUOTE] Thanks for that. But it's not the issue - I ran it maybe 2-3 seconds on jack stands while I measured the (non-) load voltage. Drove it afterwards, with the same result as before. Additionally, the issue that caused me to post has been growing for a long time (well before I did this test). It's a 48V system, 8x6V batteries. If I had to guess, a motor issue is a very, very long shot - is that correct? It seems like, in the world of electric drive, batteries are far more often the culprit as compared to a motor. |
06-08-2014, 07:54 PM | #5 |
Not Yet Wild
Join Date: Jun 2014
Posts: 13
|
Re: '99 DS, Lacking Oomph
|
06-08-2014, 08:41 PM | #6 |
Guest
Posts: n/a
|
Re: '99 DS, Lacking Oomph
|
06-09-2014, 06:19 AM | #7 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: '99 DS, Lacking Oomph
This sounds like a resent post where the left sol was failing. The cart is trying to run pulling voltage through the resistor coil of the left sol.
|
06-09-2014, 10:05 AM | #8 |
Not Yet Wild
Join Date: Jun 2014
Posts: 13
|
Re: '99 DS, Lacking Oomph
|
06-09-2014, 10:08 AM | #9 |
Not Yet Wild
Join Date: Jun 2014
Posts: 13
|
Re: '99 DS, Lacking Oomph
|
06-09-2014, 10:26 AM | #10 | |
Gone Wild
Join Date: Jul 2010
Location: Peachtree City, Ga.
Posts: 2,759
|
Re: '99 DS, Lacking Oomph
Quote:
Read the whole thing noting posts #8 and #9 in particular. |
|
Tags |
99 ds, slow, voltage |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
03 precedent 48v no oomph hot spring | Electric Club Car | |||
Batteries lacking the power | Electric EZGO | |||
G2 Primary Clutch Has No Oomph | Gas Yamaha | |||
need a little oomph in my 87 gas CC | Gas Club Car | |||
still no oomph with Beast motor.... | Electric Club Car |