|
Big Block Talk! Everything about swapping a big block engine into your cart! |
|
Thread Tools | Display Modes |
05-30-2021, 02:28 PM | #1 |
Not Yet Wild
Join Date: May 2021
Posts: 2
|
670 Predator w/ Miniki flat side- Throttle sticks
My 670cc has been running great until I feed it regular 93 octane gas. I knew i should of stayed with the ethanol free gas. Shortly after the fill up the cart started backfiring and was un-driveable. Now, it will start for a bit then shuts off within a minute. When it start if the gas is applied the RPMs climb and stay at a high RPM. This is all after the wonder local gas station. For t-shooting, . I took off the carb and cleaned but it seems the fuel pump isn't keeping fuel filter full. I'm stuck between an issue with the carb, the throttle cable sticking and the fuel filter. Any suggestions? I'll link a video to the results. Thank you
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-31-2021, 11:12 AM | #2 |
Searching for The Way
Join Date: Oct 2009
Location: Medina, Ohio (NEOHIO)
Posts: 11,436
|
Re: 670 Predator w/ Miniki flat side- Throttle sticks
Regular E10 shouldn't cause any issues instantly, the alcohol issue happens over a long period of time, corrosion and deterioration of rubber seals, gaskets, etc. One way to test that theory is to dump the fuel out and refill with your choice of E free gasoline. If it's a new carb, they are often approved for E10.
Older models might not be the case. I'm guessing there is a blockage or a fuel pump issue if you aren't getting fuel to the carb at a decent rate. It also could be a leak in the vacuum pulse hose or the fuel intake pipe/hose in the tank. |
06-01-2021, 08:45 AM | #3 |
Not Yet Wild
Join Date: May 2021
Posts: 2
|
Re: 670 Predator w/ Miniki flat side- Throttle sticks
Thank you for the reply. I have a fuel pump on order and will update after replacing.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Predator 670 in 2001 EX GO - throttle questions | Gas EZGO | |||
Predator 670cc side cover gasket | Big Block Talk! | |||
06 CC Precedent moves side to side at full throttle. | Gas Club Car | |||
clone runnin but backfiring switching gears...flat at 1/4 throttle | Gas Yamaha | |||
WARNING 16hp Duramax throttle sticks wide open | Clone Engine Swaps |