|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-14-2020, 06:49 AM | #1 |
Getting Wild
Join Date: Feb 2013
Location: Chesnee, SC
Posts: 120
|
97 TXT with new parts but no spark
97 TXT with the Robin engine. New generator, New ignitor, New solenoid, New pulsar coil, New coil, New plugs. Turns over but will never spark. Has power at the microswitch, ignition switch shuts down the engine when off as well. What the hell am i missing?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-15-2020, 07:34 AM | #2 |
Vintage tech
Join Date: Sep 2009
Location: South
Posts: 3,210
|
Re: 97 TXT with new parts but no spark
Where did you purchase all these new parts ? When did the problem start ?
|
09-16-2020, 09:34 AM | #3 |
Getting Wild
Join Date: Feb 2013
Location: Chesnee, SC
Posts: 120
|
Re: 97 TXT with new parts but no spark
The customer threw a lot of the parts at it, I figure they were cheaper parts so I swapped out the pulsar coil, ignition coil and ignitor for Red Hawk parts with no change. I'm not sure what originally started it all though, honestly.
|
09-16-2020, 11:54 AM | #4 |
Vintage tech
Join Date: Sep 2009
Location: South
Posts: 3,210
|
Re: 97 TXT with new parts but no spark
Have you checked to see if the pulser coil is generating 1/2 AC volt ?
I have never used red hawk. Only OEM from ezgo. You could very well have a wire not making good connection. Have you tested wires for continuity ? If you remove the white wire from coil and spin it over it should flash a test light. If it don't its not going to fire. Wire will stay solid if not firing. Check all the connections good. Make sure the ignitor has good connections. Check the ground wire coming from it, black with white stripe going where it shows in picture I included. There is no way to test an ignitor other than trying a known good one. They still sell the ignitors at ezgo |
01-12-2021, 09:06 PM | #5 |
Getting Wild
Join Date: Feb 2013
Location: Chesnee, SC
Posts: 120
|
Re: 97 TXT with new parts but no spark
Update :
Cart had a cheap faulty ignitor that was part of the problem. Replaced it with an oem ignitor and improved the ground and it fixed the problem. |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
no spark on g9 lots of new parts and still no luck | Gas Yamaha | |||
91 with no spark-New parts but still nothing! | Gas Club Car | |||
all new parts still no spark ! | Gas EZGO | |||
88 marathon new 79 dodge coil little spark then no spark? | Gas EZGO | |||
new parts still no spark | Gas Club Car |