|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
04-20-2017, 03:20 PM | #1 |
Not Yet Wild
Join Date: Jul 2013
Posts: 24
|
1993 electric club car
backs up but wont go forward?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-20-2017, 03:21 PM | #2 |
Gone Wild
Join Date: May 2013
Posts: 552
|
Re: 1993 electric club car
Fnr switch
|
04-20-2017, 03:24 PM | #3 |
Not Yet Wild
Join Date: Jul 2013
Posts: 24
|
Re: 1993 electric club car
removed and cleaned the switch , checks ok, but still wont go forward
|
04-20-2017, 03:42 PM | #4 |
Gone Wild
Join Date: Dec 2016
Location: Alaska/SoCal
Posts: 549
|
Re: 1993 electric club car
Could be the micro Sw on the FRN Sw with 3 wires attached.
the speed signal to the controller goes thru the micro sw,, one position is for Fwd, the other is for Rvs thru a resistor for slower speed may have bad wire, connection or Sw contacts in the Fwd position |
04-20-2017, 03:44 PM | #5 |
Gone Wild
Join Date: May 2013
Posts: 552
|
Re: 1993 electric club car
Does it go in reverse? That front micro switch. That face is talking about is signaling the juice. But if it goes in reverse and not forward wouldn't that be another issue
|
04-20-2017, 03:45 PM | #6 |
Gone Wild
Join Date: May 2013
Posts: 552
|
Re: 1993 electric club car
The third is just the half speed switch the front micro is still engaged I thought
|
04-20-2017, 03:59 PM | #7 |
Gone Wild
Join Date: Dec 2016
Location: Alaska/SoCal
Posts: 549
|
Re: 1993 electric club car
Check resistance between pin 2 & 3 on the controller
Resistance should vary as you push go. Jack up Rear of cart put in Fwd 0 to 5k Ω in Fwd or remove wires & measure resistance between the wires as you press "go" |
04-21-2017, 01:32 AM | #8 |
Gone Wild
Join Date: Apr 2014
Location: Oregon City, Or
Posts: 1,977
|
Re: 1993 electric club car
A worn cam on the F+R could trigger the 1st m/s for one direction but not the other. I'd try taking the wires off m/s. Attach a meter and cycle the F+R sw to verify. One of my cams was marginal.
. |
04-21-2017, 06:30 AM | #9 |
Guest
Posts: n/a
|
Re: 1993 electric club car
are we sure this is a controller cart ?
|
04-21-2017, 12:27 PM | #10 |
Gone Wild
Join Date: Apr 2014
Location: Oregon City, Or
Posts: 1,977
|
Re: 1993 electric club car
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Need pic of F/R wiring for electric 1993 Club Car DS | Electric Club Car | |||
1993 Electric Club Car really slow | Electric Club Car | |||
1993 Electric Club Car | Electric Club Car | |||
1993 3 wheeled electric | Electric EZGO | |||
Just bought an 36volt electric 1993 club car ds | Electric Club Car |