lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 04-05-2021, 08:51 PM   #1
sleeplesstwo
Gone Wild
 
sleeplesstwo's Avatar
E-Z-GO
 
Join Date: Jan 2015
Location: Marion, Il
Posts: 417
Default Yamaha AC Drive Won't Move Just Chatters

I am working on a 2017 AC drive Yamaha with Neos Toyota controller. It is very strange, when depressing the accelerator pedal it just chatters badly and wont move.

I first did the usual and obvious stuff. Pack voltage good, loose damaged wires, solenoid operation. I felt like it was single phasing like the three phase motors I have seen at work many times when a variable frequency drive has failed.

I checked the resistance between phases and for a possible short to motor case. I don't know specifically what it should ohm out between phases, but the numbers were consistent, so I moved on feeling like the motor is fine.

This is where it gets strange, I swapped two of the phases on the motor to see if it would possibly chatter/move in the other direction like reversing the rotation on other three phase motors, and not only did it reverse the F/R direction but cart works smooth and semi normal. Only reason I say semi-normal, is forward is reverse and vice versa. In truth I probably wouldn't care and I would just swap the selector switch, but it is reduced speed reverse... um well now forward.

Has anyone ever seen this issue before? I feel like it is pickup sensor, or corrupt programming in the controller. I am inclined to think corrupt controller software just because if I remove the pickup out of the motor and install the phases correctly, it doesn't chatter anymore but just moves forward and backward correctly but super slow (limp mode).
sleeplesstwo is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 04-06-2021, 02:26 PM   #2
Carryone
Getting Wild
 
Join Date: Jan 2010
Posts: 90
Default Re: Yamaha AC Drive Won't Move Just Chatters

Hi
do you have any Led flash on controller ?
Carryone is offline   Reply With Quote
Old 04-06-2021, 11:13 PM   #3
sleeplesstwo
Gone Wild
 
sleeplesstwo's Avatar
E-Z-GO
 
Join Date: Jan 2015
Location: Marion, Il
Posts: 417
Default Re: Yamaha AC Drive Won't Move Just Chatters

No. LED is solid green. Tried known good controller from another cart. Same issue.
sleeplesstwo is offline   Reply With Quote
Old 04-07-2021, 03:37 AM   #4
CustomCurt
Gone Wild
 
Join Date: Jan 2021
Posts: 156
Default Re: Yamaha AC Drive Won't Move Just Chatters

one bad battery cell or bad connection could do that, try adding washers to each battery post and check to see that the wires are tight rather than the nuts
CustomCurt is offline   Reply With Quote
Old 04-07-2021, 05:35 AM   #5
sleeplesstwo
Gone Wild
 
sleeplesstwo's Avatar
E-Z-GO
 
Join Date: Jan 2015
Location: Marion, Il
Posts: 417
Default Re: Yamaha AC Drive Won't Move Just Chatters

I will give the cables another check. I just kind of feel it would do it either direction. when I change any phase on the motor the cart drives great, just wrong direction.
sleeplesstwo is offline   Reply With Quote
Old 04-07-2021, 01:13 PM   #6
LPnTX
Gone Wild
 
Join Date: Oct 2014
Posts: 173
Default Re: Yamaha AC Drive Won't Move Just Chatters

My 07 Drive did the same thing when the stock Hitachi motor started to fail.
LPnTX is offline   Reply With Quote
Old 04-08-2021, 05:49 AM   #7
sleeplesstwo
Gone Wild
 
sleeplesstwo's Avatar
E-Z-GO
 
Join Date: Jan 2015
Location: Marion, Il
Posts: 417
Default Re: Yamaha AC Drive Won't Move Just Chatters

Problem solved. I removed the Tach sensor (Yamaha), or speed sensor (EZGO), for a closer inspection. I found it had a crack in the top, outside where the cable goes into the sensor. I replaced the sensor and now it's smooth as silk.

The only reason I mentioned EZGO, is that the sensor on the later RXV models is the same sensor as on the Yamaha AC Drive, or at least in this case.

I am going to assume that something hit it, or more likely when someone was installing the lift kit the installer didn't have it supported correctly and motor rolled forward damaging it. It was still working, but the signal to the controller must have been out of spec. The rollaway braking function still worked fine with the bad sensor, and if the bad sensor was pulled out of the motor, but still connected to the cart, the shuddering would stop, but cart would be in limp mode.
sleeplesstwo is offline   Reply With Quote
Old 04-08-2021, 04:13 PM   #8
rstacy
Gone Wild
Yamaha
 
Join Date: Nov 2013
Location: Western NY
Posts: 631
Default Re: Yamaha AC Drive Won't Move Just Chatters

Quote:
Originally Posted by CustomCurt View Post
one bad battery cell or bad connection could do that, try adding washers to each battery post and check to see that the wires are tight rather than the nuts
I'm glad that you got it fixed but here is something to think about and why this was a good suggestion.
Reverse uses half as much power as forward which is why a bad cell or connection may not show up in reverse.
You will see this in older cars where the car cuts out going forward but runs fine in reverse.
rstacy is offline   Reply With Quote
Old 04-08-2021, 08:36 PM   #9
sleeplesstwo
Gone Wild
 
sleeplesstwo's Avatar
E-Z-GO
 
Join Date: Jan 2015
Location: Marion, Il
Posts: 417
Default Re: Yamaha AC Drive Won't Move Just Chatters

Input always appreciated. Thank you.
sleeplesstwo is offline   Reply With Quote
Reply

Tags
3 phase, acdrive, yamaha
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
2007 Yamaha Drive won't move or charge Electric Yamaha
Yamaha drive won't move Electric Yamaha
Yamaha Drive Suspension Ideas? and tire and wheel? on Yamaha Drive with a 600cc motor On Road Golf Carts!
Yamaha Drive wont move till it warms up Electric Yamaha
96 yamaha chatters on take off Gas Yamaha


All times are GMT -5. The time now is 10:09 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.