Buggies Gone Wild Golf Cart Forum - View Single Post - Lithium RoyPow 105Ah & Conversion to 48 volts 1997 EZGO TXT

Lowliner06 · 01-07-2021, 11:03 AM

It was all pretty easy the only thing that confused me for a few minutes was the original wiring harness has a green positive for the factory /dealer installed accessories / lights and it goes across just two batteries to get 12 volts.

When I hooked up my new 48 volt to 12 volt convertor I knew the green was my original positive but did not understand the shared black negative wiring. After searching on this site there is a nice write up about just routing a new black wire back to to the original negative. In the end I decided it would be cleaner to buy a new fuse box and negative bus from AutoZone and went ahead and just redid the entire 12 volt side of the cart.

good luck with your conversion

01-07-2021, 11:03 AM	#3
Lowliner06 Not Yet Wild Join Date: Dec 2020 Location: North Carolina Posts: 4	Re: Lithium RoyPow 105Ah & Conversion to 48 volts 1997 EZGO TXT It was all pretty easy the only thing that confused me for a few minutes was the original wiring harness has a green positive for the factory /dealer installed accessories / lights and it goes across just two batteries to get 12 volts. When I hooked up my new 48 volt to 12 volt convertor I knew the green was my original positive but did not understand the shared black negative wiring. After searching on this site there is a nice write up about just routing a new black wire back to to the original negative. In the end I decided it would be cleaner to buy a new fuse box and negative bus from AutoZone and went ahead and just redid the entire 12 volt side of the cart. good luck with your conversion