Buggies Gone Wild Golf Cart Forum - View Single Post - 02 club car ds electric wont go over 5 mph

TahoeDawgZ71 · 10-26-2016, 05:02 PM

Locate the three wires on the controller plugged into terminals 1, 2, and 3. Un-plug the yellow and green wires from 2 and 3. With a multimeter set to 20k ohms, insert the leads of the multi meter into the ends of these two wires you unplugged. With the vehicle in FORWARD and the key ON, cycle the accelerator pedal from top to bottom, monitoring the reading on the screen throughout the entire throttle range. You should see approximately 6800 ohms at no throttle and approximately 1100 ohms at full throttle. Post your results and I'll tell you what you need to do next.

10-26-2016, 05:02 PM	#7
TahoeDawgZ71 revolutiongolfcars.com Join Date: Mar 2010 Location: Golf Car Capital of The World... Augusta, Georgia Posts: 10,224	Re: 02 club car ds electric wont go over 5 mph Locate the three wires on the controller plugged into terminals 1, 2, and 3. Un-plug the yellow and green wires from 2 and 3. With a multimeter set to 20k ohms, insert the leads of the multi meter into the ends of these two wires you unplugged. With the vehicle in FORWARD and the key ON, cycle the accelerator pedal from top to bottom, monitoring the reading on the screen throughout the entire throttle range. You should see approximately 6800 ohms at no throttle and approximately 1100 ohms at full throttle. Post your results and I'll tell you what you need to do next.