Buggies Gone Wild Golf Cart Forum

Buggies Gone Wild Golf Cart Forum (https://www.buggiesgonewild.com/index.php)
-   Electric EZGO (https://www.buggiesgonewild.com/forumdisplay.php?f=16)
-   -   E-Z-GO TXT48 2010+ Wiring Diagram (https://www.buggiesgonewild.com/showthread.php?t=145393)

BobBoyce 08-23-2018 06:26 AM

E-Z-GO TXT48 2010+ Wiring Diagram
 
1 Attachment(s)
I wanted to add this to the sticky for wiring diagrams, but the post was closed...

Dan33Klein 08-23-2018 06:57 AM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
I just posted a thread asking about controller diagnosing for 2010+ txt48 systems

This might help with that.

Thanks for posting!!!

kgsc 08-23-2018 07:10 AM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
Personality select? Interesting... Similar to a 1268 except looks like 3 modes.

Dan33Klein 08-23-2018 07:52 AM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
What is KSI?
I assume the green and orange wires are coming from the F/R switch?

mjroman20 08-23-2018 08:59 AM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
Quote:

Originally Posted by kgsc (Post 1534159)
Personality select? Interesting... Similar to a 1268 except looks like 3 modes.

Four actually. I've done some playing with this feature awhile back. Its a bit unusual, the switches provide 4 possible states but there are 5 operating modes available in this controller. What I've found is that with both switches floating the controller takes on whatever mode is set by the handset under the mode select/personality select (1~5). Then each combination of switches changes it to an associated mode 1~4 even if it will be a duplicate of your active mode.

For example if you set personality to 3 with the handset then setting switches results in:
0,0 - Mode 3
0,1 - Mode 2
1,0 - Mode 3
1,1 - Mode 4
Not sure if those are the exact input results but its something like that.

If I recall correctly mode 1 (airport) is not included in the switch input combos. And mode 5 (freedom) is defiantly not included.

kgsc 08-23-2018 11:30 AM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
So I guess you could use it to set a sort of high low speed configuration without needing the hand held.. Airport mode for the kidos and wide open for dad !! Wonder how it would behave if it was set at mode 5 to start with..

mjroman20 08-23-2018 12:49 PM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
No combination of switches will set airport or freedom, so if you wish to include on of those in your personality change it has to be the 'default' set by the handset. However, some of the max speed values can be adjusted for the 3 golf modes so you could put freedom on default then lower the speed if needed on one of the switchable modes.

BobBoyce 08-24-2018 07:54 AM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
Quote:

Originally Posted by BobBoyce (Post 1534146)
I wanted to add this to the sticky for wiring diagrams, but the post was closed...

The 16 pin (2 Row X 8) connector for these carts is Molex Part Number 39-01-2160, Digi-Key Part Number WM3707-ND

https://www.digikey.com/products/en?keywords=WM3707-ND

I'm making up a programming harness to support benchtop programming of the Curtis 1206HB-5201 controller used in the later TXT48 carts.

Bob

mjroman20 08-24-2018 12:25 PM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
Quote:

Originally Posted by BobBoyce (Post 1534542)
The 16 pin (2 Row X 8) connector for these carts is Molex Part Number 39-01-2160, Digi-Key Part Number WM3707-ND

https://www.digikey.com/products/en?keywords=WM3707-ND

I'm making up a programming harness to support benchtop programming of the Curtis 1206HB-5201 controller used in the later TXT48 carts.

Bob

24v on 5&9 negative on the B- tab :wink:

Dan33Klein 08-24-2018 09:26 PM

Re: E-Z-GO TXT48 2010+ Wiring Diagram
 
1 Attachment(s)
Can someone explain what the SOL+ and the SOL- from controller is???

These wires are not shown in the wiring diagrams

I’m guessing they should be the large cables.

SOL+ from batteries a
SOL- from solenoid to controller B+

Just want to confirm


All times are GMT -5. The time now is 01:06 AM.

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.