Ambient hot temperatures disables car no codes
Working on 2007 EZGO txt/pds Car runs great but intermittently stops when weather conditions get hot. When weather cools down car runs fine again. Batteries load test fine and reference power is 36.2 volts, swapped out controller, originally had a blown fusible link (60 amp). no codes are thrown when car is in diagnostic mode and problem arises. When issue is at hand no power is being sent to activate solenoid. Have continuity at the micro switch. Don't know what i am missing here. Car can be driven off the trailer to the club house ( a short distance) sit for half hour then not run or driven all day then sit for for a short while then not run, the only common denominator is the out side temperature 85 + degrees
|
Not sure but I'm pretty sure that pack is near dead
|
Re: Ambient hot temperatures disables car no codes
Quote:
batteries are at 50% http://i92.photobucket.com/albums/l2...ges-Trojan.jpg |
Re: Ambient hot temperatures disables car no codes
My 06 exgo is having the same problem!
|
Re: Ambient hot temperatures disables car no codes
Not quite sure how your figure according to your chart there at 100% unless i am reading it wrong
|
Re: Ambient hot temperatures disables car no codes
Quote:
|
Re: Ambient hot temperatures disables car no codes
does this cart have the 07 batteries? is it lifted with big tires? 36.2 is when you should stop driving it and recharge
|
Re: Ambient hot temperatures disables car no codes
Check your ITS in the floor by the micro switch. Two units on that cart are heat sensitive, The controller and the ITS.
|
Re: Ambient hot temperatures disables car no codes
src can expand on 'ITS is heat sensitive'? I live in a desert. Triple digit ambient temp is not uncommon 3 months of the year, have not seen an ITS effected by heat.
|
Re: Ambient hot temperatures disables car no codes
scotty he has an 06 pds with new noid and controller when the temp gets above 85 degrees he will drive cart runs fine then he will stop for a few min or an hour or so and cart will not move got noid clicks but no code in controller. i have no clue was hopin u or johnny b knew something
|
All times are GMT -5. The time now is 09:15 PM. |
Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.