Buggies Gone Wild Golf Cart Forum

Buggies Gone Wild Golf Cart Forum (https://www.buggiesgonewild.com/index.php)
-   Gas Yamaha (https://www.buggiesgonewild.com/forumdisplay.php?f=17)
-   -   Yamaha G1 jerks into gear (https://www.buggiesgonewild.com/showthread.php?t=110735)

nijode 09-17-2015 04:00 AM

Yamaha G1 jerks into gear
 
Just bought a Yamaha G1 which seems to run OK so far, but it shifts hard into gear. As I depress the accelerator it goes from 'Out of Gear' to 'In' with a jerk which often 'chirps' the rear wheels. Besides whiplash I'm worried about damaging something. Any ideas? All help appreciated. I'm believe that it is a G1 because it has bucket seats.

smokindawg 09-17-2015 04:10 AM

Re: Yamaha G1 jerks into gear
 
Sounds like a problem in the belt clutch area. These being older carts get wear on the belts causing them too have too much slack which could be your problem.

The clutches also get dry and worn.

I'd check the belt for width and see how tight it is. Also check the condition. May be time for a new one.

First, jack up the rear of the cart and set it on blocks/jack stands. Make sure it is steady and then start the cart and push the throttle down and see how high in the sheaves the belt is going on the drive clutch and how low in the driven clutch at full throttle and make sure the belt is setting down completely in the drive clutch and at the top of the driven clutch at an idle. See how they all look as you run thru various speeds. Watch for wobble of sheaves and listen for any unusual noises.

Check the wear pads on the driven clutch and then take a look at the spring. Take the cover off the drive clutch and see how things look. There are many posts on how too remove and lube the clutch as well and I'd do that. I'd also remove the driven clutch and lube the shaft.


All times are GMT -5. The time now is 01:00 AM.

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.