2001 Club Car Sputtering, Barely Charging
Hello, I am new to the Golf Cart world. Well, sort of. I worked at a Golf Course for many years, but we always had gas carts, so I am new to the Electric Golf Cart World haha.
We just bought a used 48V 2001 Electric Club Car. It ran pretty well last fall, only ran it 4-5 time for about 20-30 minutes a clip. After the winter, I charged her up and ran it once! Took about a 10 minute ride around the neighborhood, and as I am pulling back to the backyard it started losing power. So, I charged it up, and boom nothing. At most, I am getting a consistent sputter. Nothing is moving, and the horn/lights won't even come on. The batteries were tested by a buddy, and they seem to be charging, but very very slowly. The charge is only charging at like 5 amps or less, often it shuts off before ever finishing the charge job. Am I having a charger problem? A motor problem? Or a battery problem? |
Re: 2001 Club Car Sputtering, Barely Charging
Sounds like a bad connection somewhere. Inspect all of your power cables on your batteries and make sure none of them are corroded and/or about to break off.
|
Re: 2001 Club Car Sputtering, Barely Charging
Like Tahoe said, bad connection. Check the battery cable ends. ANY corrosion needs to be removed, and if cables are damaged they need to be replaced ASAP.
Also check the voltage of each battery. You should have above 8 volts one each battery. Preferably you need 8.49 volts per battery if they have a full charge. Any that are below 8 volts minimum are a problem. |
Re: 2001 Club Car Sputtering, Barely Charging
...I will double check when I get home tonight, but have a feeling my buddy was saying there was only like 2-3 volts per battery, meaning 12-18 volts total? - May not be enough to get the charger running?
|
Re: 2001 Club Car Sputtering, Barely Charging
If they're that low the charger wouldn't even turn on.
If you have one or two that are that low, the charger may turn on, but it may not be able to charge them properly. Any battery that is that low is DEAD, and there is no bringing it back. If that's the case you need an entire new set of batteries. |
Re: 2001 Club Car Sputtering, Barely Charging
Quote:
|
All times are GMT -5. The time now is 03:46 AM. |
Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.