07 clubcar ds 48v. will not move F or R no click from solenoid
Good Evening. I have a 07 lub car put new Trojan Batteries in, test drove it around everything was fine so I parked it. Went out next day to drive it nothing no click at solenoid. I have tested a few things but still not sure what is problem. I have no low at solenoid. when i take low to batt neg solenoid engages and pass pack voltage to controller which is 51v. i can depress pedal when solenoid is jumped and still no movement from wheels. also I have no reverse buzzer when in reverse. My cart has the rocker switch and the tow switch. my model # is AQ0728-778074. Any Help will be greatly appreciated.
|
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
Key on and FNR rocker in F or R and run/tow switch in run?
Not sure what you mean about "taking and having low?" |
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
correct key on switch in f or R depress pedal nothing. buzzer does not sound in Reverse.
by taking the low to batt neg. I mean took blu/wht wire off solenoid and ran jumper to batt. neg. solemoid clicks and passes pack voltage to big yellow wire on controller. depress pedal cart will still not move. |
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
While we wait on an expert for that drive system, check the fuse at the run/tow switch.
|
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
That sounds bad as a IQ cart (Your AQ) is a sepex and has a logic controller. You have to have all the premissives for the controller to pull low, but you usually will have the reverse buzzer (unless the switch is bad) as it is triggered differently.
|
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
Do this with one wheel jacked up. Get your DVM and place the Black probe on the pack Neg and then with the key On, cart in Fwd, and Go Pedal depressed far enough to hear the microswitch click, take the Red probe and check to see if you have pack voltage in the following pins at the controller: Pin 5 - Lgt Blue, Pin 6 - Green, Pin 8 - Brown, Pin 9 - Grey, and Pin 10 - Tan.
|
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
Quote:
|
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
Quote:
akwood, sorry if I sent you on a wild goose chase. |
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
checked fuses all good.. should'nt the controller put out voltage with the solenoil jumpped out and the pedal depressed
|
Re: 07 clubcar ds 48v. will not move F or R no click from solenoid
I will check those pins for voltage
|
All times are GMT -5. The time now is 03:35 PM. |
Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.