Your Custom Radio and Speaker installations
Let see the pics!
If this has been done I apologize. (but I did search first) |
Re: Your Custom Radio and Speaker installations
Anybody?
|
Re: Your Custom Radio and Speaker installations
Radio box is built out of wood and mounted to dash with metal L brackets on either side in the front. The speaker brackets are screwed into the floorboard with self-tapping metal screws. They are pushed tight to the side and up to prevent much movement. All wires are run under the front in wire loom and tied up. Power is ran under floorboard for both standby power and key-activated ON signal. There are also wires for the rear channel ran to the back of the engine compartment for future use.
The radio is a Sony 200 total watt Xplod deck with CD, AM/FM, and 1/8" AUX input. The speakers are 3-way Best Buy specials that cost around $20! They have nice bass, are water-resistant, and self contained! http://inlinethumb56.webshots.com/50...600x600Q85.jpg http://inlinethumb37.webshots.com/59...600x600Q85.jpg |
Re: Your Custom Radio and Speaker installations
|
Re: Your Custom Radio and Speaker installations
Here's what I have done on Yamaha G-14 thru G-22. I built a template and bought a sheet of black ABS plastic and put in the right cubbie hole. I have put them in the left hole but it is a little smaller and the waterproof cover will not fit without trimming it ,so I moved them to the right side and buy cd player with remotes. The antenna goes under the front cowl so it is not visible.
http://i35.photobucket.com/albums/d1...gtn/radio3.jpg http://i35.photobucket.com/albums/d1...gtn/radio4.jpg http://i35.photobucket.com/albums/d1...n/speakers.jpg |
Re: Your Custom Radio and Speaker installations
[QUOTE=gornoman;63719]http://i92.photobucket.com/albums/l2...ornoman_04.jpg
QUOTE] That's an awesome setup. How'd you make it? |
Re: Your Custom Radio and Speaker installations
3 Attachment(s)
Here are some pics of my setup. I have a Poly Planar Amp and Speakers all marine grade waterproof. I custom built the dash inserts. The amp power is controlled by the key switch. I can run any portable player into the input jack. I mostly use my Samsung XM radio, which also holds recorded content and MP3s. The docking cradle mounts just above where the cupholders are (that connects to the satellite antenna on the roof), I don't have a picture of that hooked up here. So far it works great, is plenty loud enough, and doesn't drain the battery too badly (even if I let it play for quite awhile without running the engine). :thumbup:
|
Re: Your Custom Radio and Speaker installations
Quote:
This one is MDF covered in vinyl. It is held to the roof with four sealed bolts that were spaced to penetrate the roof at those depressions in the E-Z-Go roofs. Very clever setup and trouble free, the CD never skips, and the components never get wet. It's like wearing headphones. I can play it very quietly and not disturb anyone, or let it rip and...... .....make my wife mad! |
Re: Your Custom Radio and Speaker installations
2 Attachment(s)
Here is what I did with some fiberglass and some help of beer
|
Re: Your Custom Radio and Speaker installations
The most recent project on RoadRunner was the addition of a stereo; you can see one of the speakers in the kickpanel
http://www.cart.themonniers.com/images/080413-4029.jpg The radio install.... This ended up being far more time consuming than I had thought :-D . I spent altogether TOO much time trying to fish the wires down the aluminum windshield supports. I finally gave up :( and ran the 6 wires down the outside, inside of some loom tywrapped to the supports. Perhaps someday I'll give another shot to getting the wires inside the support. I settled on a Sony radio from West Marine, mainly because the speakers were intended for use on a boat, where they could (and would) get wet. I also went for the full waterproof enclosure to mount the radio chassis in (also from West). That way when the cart gets washed, no worries. The radio sounds great :-o , now while we are watching the sunset over the marshes, enjoying our 'grape juice', we can have some mood music....... http://www.cart.themonniers.com/images/080413-4037.jpg Since the pic's were taken, the speakers have been repainted black, under a directive from SWMBO.... I had several votes for yellow, but...... |
All times are GMT -5. The time now is 04:52 AM. |
Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.