Buggies Gone Wild Golf Cart Forum

Buggies Gone Wild Golf Cart Forum (https://www.buggiesgonewild.com/index.php)
-   Electric Club Car (https://www.buggiesgonewild.com/forumdisplay.php?f=13)
-   -   Club Cart dead (https://www.buggiesgonewild.com/showthread.php?t=158726)

baller32 11-08-2019 09:48 AM

Club Cart dead
 
So over the weekend I installed a simple battery meter on my 2010 club car. I used the existing wires, all I needed to do was plug them in to the meter. While I was doing that and cutting the hole for the meter, my connection for my light switch came off. This is a light I installed using a voltage reducer, fed into a fuse box. While I was trying to get the wire back onto my switch my pliers sparked something on that switch. Now my cart is dead.
I have no reverse buzzer, I have nothing. I checked my fuse to the light, the fuse to the voltage reducer. I have disconnected the positive and negative battery pack for 15 min and then reconnected and flipped the tow switch to run......
I had the tow switch to off when I was hooking things up, but wanted to make sure the battery meter was working so I switched it on and just left it on because everything was hooked up until my stupid light switch came off. However with it running through a fuse and running through the voltage reducer fuse I didn't think I needed to switch the tow back to off........
Any ideas what happened and how I can fix this stupid cart.

CoiloverCarts 11-08-2019 09:55 AM

Re: Club Cart dead
 
Main fuse in the controller box, there should be a 30a fuse (I believe). It is located behind the black access panel in the bag well or climb under the cart there will be a black cover with 3 to 4 tabs holding it on. In there on the drivers side (usually) will be a large fuse. I bet that is the culprit.

Sent from my SM-N960U using Tapatalk

baller32 11-08-2019 10:17 AM

Re: Club Cart dead
 
I will give that a look! Why wouldn't it pop the inline fuse first?

CoiloverCarts 11-08-2019 10:23 AM

Re: Club Cart dead
 
If you arced the key switch or another component not ran thru your fuse block then that is the inline fuse that would blow to protect the controller, ect

Sent from my SM-N960U using Tapatalk

baller32 11-11-2019 03:25 PM

Re: Club Cart dead
 
Yup, fuse was popped in bag well compartment! All is good now!
Thanks CoiloverCarts!


All times are GMT -5. The time now is 04:00 PM.

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.