1995 DS 48v series cart. I’me stumped?
 

I picked up a 1995 club car DS powerdrive 48v with brand new US batteries and factory rear seat set up for 800$. The price was because the guy thought the cart needed new batteries so he got a set. No go. So he replaced the selanoid. No go. So he replaced the micro switches on the FNR lever and still no go. He cut his losses. I got the cart and found that with the key on and forward lever engaged when you hit the gas pedal it lurches forward about 1 inch and stops. The selanoid is not clicking? I assumed that the gas pedal ( this one has a pot switch set up with another small micro switch inside the plastic pot switch housing) was bad so I tore into it and found the micro switch was seized up and would not “click”. I replaced that micro switch hoping that was the issue but it wasn’t. Same thing ..... turn the key on, put in forward and it lurches about a inch and nothing. No selanoid click?

*note* when you place cart in forward it will lurch forward an inch only once. You have to then put it into reverse and then press the pedal again to get it to slightly move about one inch without selanoid engagement again.

Also, I noticed that the large resister that connects the two large posts of the selanoid gets hot if I hold the pedal depressed in either Forward or Reverse.

I am not a avid electrician and not great with DC currents but am willing to learn. It’s not that I can’t learn it, I just never have so where do I start? I am thinking that based on other reads on this forum the controller may be the culprit. BTW the cart is in phenomenal shape for its age and appears to have been a gated community type of cart it’s whole life.

Re: 1995 DS 48v series cart. I’me stumped?
 

I will post some pics of the selanoid, controller, and pot micro switch this evening if I can figure out how to pull pics from my phone and post them to a forum😬

Re: 1995 DS 48v series cart. I’me stumped?
 

Pics

Re: 1995 DS 48v series cart. I’me stumped?
 

Try taking the small yellow wire off solenoid small stud get a wire run it to battery negative the other end to where the yellow wire was see if it energizes the solenoid

Re: 1995 DS 48v series cart. I’me stumped?
 

:thumbup:

Re: 1995 DS 48v series cart. I’me stumped?
 

Could be a bad micro switch in the v-glide.

Re: 1995 DS 48v series cart. I’me stumped?
 

It doesn't have a V glide it has the 95-96 pot.

Re: 1995 DS 48v series cart. I’me stumped?
 

Scotty, if it's trying to run on voltage through the resistor doesn't that mean the micro in the pot is good?

Re: 1995 DS 48v series cart. I’me stumped?
 

Okay - Solenoid not activating so it's missing + or - ... or the solenoid is bad.
And yes - the 95 has a switch in the pot not a v-glide. The pot and vglide perform the same function.
My advice was that switch could be the problem.

Re: 1995 DS 48v series cart. I’me stumped?
 

Anziosaint, where did you find that micro switch?